Vgi Lithium Polymer Msds v3

Vertical Partners West, LLCUpdate: July 1, 2013 MATERIAL SAFETY DATA SHEET 24 Hour Emergency Contact CHEMTREC 1-800-424-9300 NOTE: National Response Center emergency number to be used only in the event of chemical emergencies involving a spill, leak, fire, exposure or accident involving chemicals. IMPORTANT: Provide this information to employees, customers, and users of this product. Read this MSDS before handling or disposing of this product. This product is covered by the OSHA Hazard Communication Standard and this document has been prepared in accordance with requirements of this standard. SECTION 1: Company: Brands: Address: Telephone: Fax: Emergency Contact: Company Identification Vertical Partners West, LLC Venom, Atomik RC, Steerix 14028 N. Ohio Street, Rathdrum, Idaho 83858 General Business General Business CHEMTREC 1-800-705-0620 1-208-712-3053 1-800-424-9300 SECTION 2: Product Name: Battery Type: DOT Description: Models: Product Identification Venom Power – Lithium Polymer Batteries Rechargeable Lithium Polymer (LiPO) Lithium Ion (Polymer); Secondary Battery; Rechargeable Page 1 of 13 Copyright ©2013 Vertical Partners West, LLC. All rights reserved. UNI 20C 2S 5400mah 7.Hard Case 25C 2S 3300mah 7.Vertical Partners West.Uni 20C 3200mah 7.1v LiPO .1v LiPO .MCX 15C 2S 250mah 7.4v LiPO Batt w/JST 20C 2S 800mah 7.1v LiPO .1v LiPO .UNI 10C 7.4v 2-Cell RX LiPO FLAT 10C 1200mah 7.Uni 25C 2S 4100mah 7.7v LiPO .8v 4-Cell LiPO Battery 25C 5S 3600mah 18.Uni 10C 1600mah 7. All rights reserved.1v 800mah 3-Cell LiPO Battery 25C 3S 7500mah 11.1v LiPO .1v TX Pack .UNI Plug 20C 3S 5000mah 11.5v 5-Cell LiPO Battery 30C 6S 3200mah 22.4v 2-Cell R/C Car LiPO UNI .4v R/C Car LiPO UNI 20C 3S 6400mah 11.2v 6-Cell LiPO Battery 25C 4S 5000mah 14.4v LiPO Battery UNI 20C 3S 1300mah 11.8v 4-Cell LiPO Battery 30C 5S 3200mah 18.1v LiPO .1v LiPo Battery + Bullet Connector 25C 1S 250mAh 3.UNI 3000mah 11.1v R/C Car LiPO .4v 2-Cell RX LiPO HUMP 20C 3S 2100mah 11.Hard Case 20C 4000mah 7.UNI 20C 3S 4000mah 11.7V LiPO – Blade MCPX 2400 mah 7.Uni 25C 2S 5000mah 7.UNI 20C 2S 8000mah 7.1v LiPo Battery + Bullet Connector 20C 3S 950mah 11.M11 . LLC 1549 1550 1551 1552 1553 1554 1555 1556 1557 1558 1559 1560 1577 1580 1581 1582 1583 1584 1585 1586 1587 1588 15000 15001 15002 15003 15004 15005 15006 15007 15008 15009 15010 15011 15012 15013 15014 15015 15016 15017 15018 15019 15020 15021 15023 15024 845623025197 845623005816 845623000002 845623024480 845623004055 845623004079 873067007493 845623024275 845623024282 845623024299 873067007417 873067007424 873067003457 845623001887 845623001894 845623008985 845623018861 845623018878 845623023568 845623024008 845623024015 845623025692 845623009098 845623009104 845623009111 845623009128 845623009135 845623009142 845623009159 845623009166 845623009173 845623009180 845623009197 845623009203 845623009210 845623009227 845623009234 845623009241 845623009258 845623009265 845623009272 845623009289 845623009296 845623009302 845623010667 845623010674 Update: July 1. Helios 30C 4S 3200mah 14.2v 6-Cell LiPO Battery 20C 2S 2000mah 7.4v 2-Cell R/C Car LiPO UNI .Z-1.4v LiPO Hardcase .7v LiPO . LLC.2v 6-Cell LiPO Battery 25C 4S 3600mah 14.4v R/C Car LiPO .4v 2-Cell R/C Car LiPO UNI .MCX 25C 150mah 3.5v 5-Cell LiPO Battery 25C 6S 3600mah 22.UNI 20C 3S 3200mah 11.8v 4-Cell LiPO Battery 25C 5S 5000mah 18.MX3 2400mah 11.UNI Plug 20C 3S 5400mah 11. .Hard Case 20C 5000mah 7.1v TX Pack .1v LiPO .4v 1250mAh 2-Cell LiPO Battery 10C 11.4v LiPO Batt w/JST 20C 4S 2100mah 14.8v LiPO for Starter Box 13C 2S 1320mah 7.4v 2-cell LiPO RX Hump pack 20C 2S 430mah 7.4v LiPO Hardcase . 2013 20C 8000mAh 7.5v 5-Cell LiPO Battery 25C 6S 5000mah 22.4v 2-Cell LiPO Hard Case .UNI Plug 25C 120mah 3.4v LiPO w/JST 13C 3S 1320mah 11.4v 2-cell LiPO RX Flat pack 2100 mah 7.1/24 Losi 20C 3S 850mah 11.1v LiPO Batt UNI Page 2 of 13 Copyright ©2013 Vertical Partners West.4v LiPO Battery .4v LiPO Hardcase . UNI 50C 3S 2200mah 11.8v Hard Case Lipo 35C 5S 3800mah 18.8v Hard Case Lipo 50C 2S 4500mah 7.4v Sport Power LiPO-UNI 50C 3S 5000mah 11.UNI 60C 2S 3800mah 7.UNI 70C 4S 14.7v Hardcase LiPo .UNI 35C 2S 7.UNI 70C 1S 3.UNI 70C 2S 7.8v LiPO Battery 50C 5S 5000mah 18. LLC.UNI 40C 2S 4000mah 7.8v Hardcase LiPO .UNI 35C 4S 4500mAh 14.4v Sport Power LiPO-UNI 40C 2S 5000mah 7.4V 8000mAh LiPO .UNI 60C 2S 5000mah 7.5v LiPO Battery 50C 6S 3600mah 22.1V 3300mAh LiPO Hard Case .5v LiPO Battery 50C 6S 5000mah 22.4v Sport Power LiPO-UNI 50C 2S 5000mah 7.2v LiPO Battery 50C 4S 5000mah 14.2v Hard Case Lipo 50C 2S 5000mah 7.4V 10000mAh LiPO .4V 7000mAh LiPO Hard Case .2v LiPO Battery 40C 4S 3500mah 14.4v Hardcase LiPO .2v LiPO 35C 3S 5000mah 11.4V LiPO w/ Voltage Check .5v Hard Case Lipo 25C 6S 3200mah 22.1v LiPO .Uni 50C 1S 5000mah 3. LLC 15025 15026 15027 15028 15029 15030 15031 15032 15033 15036 15037 15038 15040 15041 15042 15043 15044 15045 15046 15047 15048 15049 15056 15057 15058 15059 15060 15061 15064 15067 15068 15079 15091 15092 15093 15094 15070 15071 15072 15073 15074 15075 15080 15081 15083 15084 15085 15086 845623015389 845623015396 845623015402 845623015419 845623015426 845623016881 845623016898 845623016904 845623018922 845623023575 845623023582 845623024459 845623016911 845623016928 845623016935 845623016942 845623016959 845623016966 845623016973 845623016980 845623016997 845623024466 845623024343 845623024350 845623024367 84562324473 845623017208 845623017215 845623024305 845623038951 845623038968 845623039033 845623038982 845623038999 845623039002 845623039019 845623024312 845623024329 845623024336 845623025470 845623025487 845623025685 845623010223 845623010230 845623010254 845623011008 845623011015 845623017123 Update: July 1.UNI 35C 2S 7.4V 5200mAh LiPO .UNI 30C 3S 3200mah 11.1v LiPO Hardcase .UNI 30C 5000mah 7.4v LiPO Saddlepack 40C 5000mah 7.4v Hardcase LiPO . All rights reserved.5v LiPO Battery 50C 6S 2500mah 22.4v LiPO Battery Hard Case 20C 4000mah 7.4v LiPO Hardcase .4v Saddle Pack Hard Case 40C 3S 2200mAh 11.1V LiPO Battery .UNI 35C 2S 7. 2013 25C 6S 2500mah 22.4v Hardcase LiPO Page 3 of 13 Copyright ©2013 Vertical Partners West.8v LiPO Hrdcase .4V LiPO .4v LiPO Deans + Sockets 35C 3800mah 7.7V 6300mAh LiPO Hard Case .8v LiPO Battery 50C 5S 3600mah 18.4v LiPO fits Tamiya Cars 50C 5000mah 7.UNI 70C 2S 5800mah 7.UNI 25C 2S 10000mAh 7.UNI 35C 3S 11.UNI 35C 4S 5000mah 14. .2v LiPO Battery 50C 4S 3600mah 14.4v Hardcase LiPO .8v LiPO Battery 50C 5S 2500mah 18.1v LiPO .4v LiPO Deans + Sockets 30C 4200mah 7.8V 6300mAh LiPO Hard Case .UNI 60C 2S 5600mah 7.8V lip w/ Voltage Check .4v Hardcase LiPO .UNI 70C 4S 5300mah 14.UNI 50C 4S 2500mah 14.UNI 70C 2S 5300mah 7.UNI 20C 2S 4500mAh 7.1v LiPO Battery .4v Hard Case Lipo 50C 4S 5000mah 14.Vertical Partners West. Silver A-10 Thunderbolt RC Jet PNP .White Thunder RTF Mini 4CH RC Heli Travel Copter RTF Mini 4CH RC Heli Police RTF Mini 4CH RC Heli Superfine RTF Mini 4CH RC Heli A-10 Thunderbolt RC Jet RTF .Desert 1S 110mah 3.Airsoft RC Models that Contain a LiPO Battery: 6050 845623007629 6053 845623011459 6054 845623015341 6055 845623015358 6056 845623016690 6057 845623016768 6201 845623002754 6206 845623007025 6242A 845623009968 6242B 845623010087 6242C 845623010094 C6035 845623038043 C6036 845623038050 C6039 845623038067 C6041 845623038029 C6042 845623038036 C6043 845623038012 C6044 845623037978 C6045 845623037985 C6047A 845623037992 C6047B 845623038005 JA10-1-7191 JP03-8040-2 mDX186 mDX188 mDX189 mSP190 SN06-5073-2 SN07-5089-2 SN08-5103-2 JA12-7210-2 WK-GeniusV2Devo7 WK-InfraX-Devo4 WK-V120D02S WK-4F200LM 18000 18000BLEM WK-V200D03 WK-LBV2-Devo4 WK-LBV2-F4 845623033536 845623033581 845623038074 845623038081 845623038098 845623038104 845623033291 845623033307 845623033314 845623035608 845623039118 845623039088 845623039095 845623039149 845623027528 845623032386 845623039170 845623039071 845623039064 Venom Kona Kopter .Vertical Partners West. . LLC.1S 90mah 3.Blue/Red F-15 RC Jet RTF .Desert Camouflage Mig-29 RC Jet RTF .7V Venom Switch .7V Micro Troop Transporter .7mah Apache Micro V-Pro Venom Ozone Elite Venom Beacon Black Hawk Helicopter .1V 1200mah LiPO .EDF Version Genius CP V2 6Ch RTF Heli w/ Devo7 InfraX RTF Quadcopter w/ Devo4 V120D02S 6Ch RTF Heli w/ Devo7 4F200LM 6Ch RTF Heli w/ Devo7 Atomik Whiplash 24 RTR Electric RC Boat Atomik Whiplash 24 RTR Electric Boat-BLEM V200D03 6Ch RTF Heli w/ Devo7 Ladybird V2 RTF Quadcopter w/ Devo4 Ladybird V2 RTF FPV Quadcopter w/ Devo F4 Page 4 of 13 Copyright ©2013 Vertical Partners West.Desert Camo .4v Hardcase LiPO 15C 3S 11. LLC 15087 15307 15308 845623017130 845623025210 845623025227 Update: July 1. All rights reserved.1S 110mah 3.7V Micro Troop Transporter .Jungle 1S 110mah 3.7V X2 Max Flight 4CH RTF Micro RC Heli RA-52 4CH RTF Micro RC Heli Lama 4Ch RTF Micro RC Heli Fly Soccer 3CH RTF RC Heli Fly Soccer Mini 3CH RTF RC Heli Lady Bug 4CH RTF Micro RC Quadcopter UFO 4CH RTF Micro RC Quadcopter AirShip 3CH RTF Micro RC Heli Scorpion S-Max RTF Micro RC Multi Rotor Heli Scorpion S-Max RTF Micro RC Multi Rotor Heli .1V 1500mah LiPO .Airsoft 30C 3S 11.Sea 1S 110mah 3.Red/Blue Explorer RC Jet RTF .7V Micro Troop Transporter .w/ESC and Servos Sky Surfer RC Airplane RTF .1S 110mah 3.7V Venom Kodiak Helicopter 1S 500mah 3. 2013 50C 5600mah 7. Vertical Partners West. . All rights reserved. 2013 Mini CP 6Ch RTF Heli w/ Devo7 Super CP 6Ch RTF Heli w/ Devo7E Master CP 6Ch RTF Heli w/ Devo7 V450D01 6Ch RTF Heli w/ Devo10 V450D03 6Ch RTF Heli w/ Devo7 J3 CUB ARF Brushless RC Airplane J3 CUB RTF Brushless RC Airplane Invader RTF RC Airplane Smart-K RTF RC Airplane Smart-K ARF Brushless RC Airplane Smart-K RTF Brushless RC Airplane Mad Shark F1 RTR RC Boat Offshore Warrior Lite RTR RC Boat Offshore Sea Rider Lite RTR RC Boat 1/18 Barren 4WD BL RTR Buggy 1/18 Mastadon 4WD BL RTR Monster Truck 1/18 Tyronno 4WD BL RTR SC Truck 1/18 Spino 4WD BL RTR Buggy 1/18 Centro 4WD BL RTR Truggy 1/10 Bowie 4WD BL RTR Monster Truck 1/10 Spatha 4WD BL RTR SC Truck 1/10 Tanto 4WD BL RTR Buggy 1/10 Katana 4WD BL RTR Truggy 1/4 Burstout RTR Motorcycle 1/8 Raider 4WD RTR Monster Truck 1/8 Mayhem 4WD RTR SC Truck 1/8 Shootout 4WD RTR Buggy 1/8 Ziege 4WD RTR Truggy Super Cub ARF Brushless RC Airplane Super Cub RTF Brushless RC Airplane Freeman 1600 ARF RC Glider Freeman 1600 RTF RC Glider Invader ARF Brushless RC Airplane Invader RTF Brushless RC Airplane Explorer RC Jet RTF . LLC. LLC WK-MiniCP-Devo7 WK-SuperCP-Devo7 WK-MasterCPDevo7 WK-V450D01 WK-V450D03 J6202 J6202-1 J6104 J6106 J6107 J6107-1 J8203 J8206 J8208 E18DBL E18MTL E18SCL E18XBL E18XTL E10MTL E10SCL E10XBL E10XTL MX400BL MegaE8MTL MegaE8SCL MegaE8XBL MegaE8XTL J6203 J6203-1 J6103 J6103-1 J6105 J6105-1 JP08-8090-2 6055 6057 18004 9201 845623039101 845623039125 845623039132 845623039163 845623039156 845623036254 845623036261 845623036209 845623036179 845623036186 845623036193 845623036094 845623036070 845623036087 845623038364 845623038289 845623038272 845623038265 845623038296 845623038562 845623038555 845623038524 845623038579 845623038753 845623038838 845623038807 845623038777 845623038845 845623036278 845623036285 845623036230 845623036247 845623036216 845623036223 845623035622 845623015358 845623016768 845623030795 845623025630 Update: July 1.Prop Version Steerix Apache RC Heli Steerix Ozone Elite RC Heli Atomik Barbwire RTR Brushless RC Boat 1/8 Brian Deegan Metal Mulisha Ford Raptor 150 RTR SC Truck Page 5 of 13 Copyright ©2013 Vertical Partners West. During water application. Seek medical attention immediately. LLC Update: July 1. water or Foam Extinguishers Fire-Fighting Procedures: Use a positive pressure self-contained breathing apparatus if batteries are involved in a fire. 7429-90-5 7429-90-5 7440-50-8 12190-79-3 7440-02-0 Approximate Percentage of Total Weight 2-10% 5-15% 10-30% 5-15% 20-40% 1-5% 0. caution is advised as Page 6 of 13 Copyright ©2013 Vertical Partners West.5-5% 10-25% 3-10% Aluminum Packaging Foil Carbon (Various Forms) Copper Lithium Cobalt Oxide Lithium Salts Nickel Organic Carbonate Polymer SECTION 4: Appearance: SECTION 5: Physical/Chemical Characteristics 3 Dimensional Rectangular Solid Object with Black or Silver outside covering and two wires [positive (red) and negative (black)]. Fire Fighting Measures Extinguishing Media: CO2. Emergency and First Aid Procedures In the event of accidental battery material contact due to a damaged or ruptured battery cell please follow these emergency guidelines: Eye Contact: Skin Contact: Inhalation of Gases: Ingestion: SECTION 6: Immediately Flush eyes with water for 15 minutes and seek medical attention. 2013 SECTION 3: Components Aluminum Hazardous Ingredients / Identity Information CAS No. Dry chemicals.Vertical Partners West. Immediately move affected victims to fresh air or well ventilated areas and seek medical attention. LLC. Full protective clothing is necessary. All rights reserved. Immediately wash affected area with soap and water. . Page 7 of 13 Copyright ©2013 Vertical Partners West. Do not mix with other types of batteries or other battery sizes or capacities. All rights reserved. well ventilated. LLC. destroyed or incinerated as doing so may lead to leakage. non-flammable. 2013 burning pieces of flammable particles may be ejected from the fire. Batteries should only be recharged using approved chargers and approved procedures. SECTION 8: Handling: Handling and Storage Batteries should never be opened. Unusual Fire and Explosion Hazards: Toxic gases (HF. well ventilated area. Vapors may be heavier than air and may travel along the ground or be moved by ventilation to an ignition source and flash back. . rupture. Storage: Batteries should be separated from other materials and stored in a non-combustible. throw in fire or solder directly. Use a shovel or broom to cover the battery with dry sand and place in a non-flammable. Cells or battery may flame or leak potentially hazardous organic vapors if exposed to excessive heat. Do not directly heat.Vertical Partners West. sprinkler-protected structure with sufficient clearance between walls and batteries. PF6) will be formed if cells or battery are involved in a fire. Damaged or opened cells or batteries may result in rapid heat and the release of flammable vapors. LLC Update: July 1. or fire and the materials contained inside may be released. fire or over-voltage conditions. Accidental Release Measures SECTION 7: The materials contained within the batteries can only be released under abusive conditions. dry area that is subject to little temperature change. deform.Vertical Partners West. short circuit. Page 8 of 13 Copyright ©2013 Vertical Partners West. SCBA should be worn along with thermally protective outer garments. Personal protective equipment for damaged batteries should include chemical resistant gloves and safety glasses. Battery exposure to temperatures in excess of 130°C (260°F) will result in the battery venting flammable liquid and gases. Do not puncture. LLC. 2013 Do not place batteries near heating equipment. All rights reserved. disassemble. Elevated temperatures can result in reduced battery service life. . LLC Update: July 1. Do not heat above 60ºC or incinerate. SECTION 10: Reactivity and Stability Data Extended short-circuiting creates high temperatures in the cell. Store batteries in a cool (below 21°C (70ºF)). High temperatures can cause burns in skin or cause the cell to flame. Do not store batteries in a manner that allows terminals to short circuit. nor expose to direct sunlight for long periods of time. Do not store batteries above 60ºC (140ºF) or below –32ºC (-25ºF). In the event of a fire. To do so may cause cell to flame or to leak. SECTION 9: Personal Protection No controls are required for handling batteries that have not been damaged. crush or mutilate. Avoid reversing battery polarity within the battery assembly. More than a momentary short circuit will cause temporary battery voltage loss until the battery is subjected to a charge. All rights reserved. batteries must be quarantined. SECTION 12: Not Known SECTION 13: Transport Information Ecological Information These batteries have been tested to Section 38. call CHEMTREC 1-800-424-9300 Transport Method Air Sea Land International Conventions International Air Transportation Association (IATA) International Maritime Dangerous Goods (IMDG) U. The amount of Lithium contained in these batteries is below the limits set by the Department of Transportation (DOT) in Section 49CFR173 and IATA. LLC. .Vertical Partners West. 2013 SECTION 11: Toxicological Information Irritancy: The electrolytes contained in this battery can irritate eyes with any contact. LLC Update: July 1. For emergency information. Department of Transportation (DOT) Regulatory Information Ship As NonHazardous NonHazardous NonHazardous Approved Yes Yes Yes SECTION 14: Page 9 of 13 Copyright ©2013 Vertical Partners West.3 of ‘UN Manual of Tests and Criteria’. Prolonged contact with the skin or mucous membranes may cause irritation. These can be shipped with the following label: LITHIUM POLYMER (LiPO) RECHARGEABLE BATTERIES INSIDE (No Lithium Metal) • • • Do not damage or mishandle this package If package is damaged.S. inspected and repacked. 3. International: PRODUCT USAGE INSTRUCTIONS SECTION 15: Safety During Use Instructions 1. . All rights reserved. This MSDS conforms to European Union (EU). Do not charge batteries on wood. Hazardous Materials Regulations (HMR). (49 CFR Sections 173-185) of the U. in your model. swollen or appears damaged. the International Standards Organization (ISO) and the International Labour Organization (ILO) and as documented in ANSI (American National Standards Institute) Standard Z400.Vertical Partners West. Follow the disposal instructions below to properly and safely dispose the battery. Never leave batteries unattended while charging. LLC Update: July 1. carpet. Always observe batteries when charging so that you may react quickly to any problems that may occur. Failure to do so will damage the batteries and may cause fire and personal injury. USA: Canada: This MSDS meets/exceeds OSHA requirements. If a battery is deformed. LLC. DO NOT CHARGE. Always charge batteries in a fire proof container. 4. Always use a charger specifically designed for Lithium Polymer batteries. Page 10 of 13 Copyright ©2013 Vertical Partners West.11993. Keep a chemical fire extinguisher near by in case of fire. 2013 The transportation of rechargeable lithium polymer cells and batteries is regulated by the United States in accordance with Part 49 of the Code of Federal Regulations. cloth. This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by those regulations. and the International Maritime Dangerous Goods (IMDG) Code. or on any other flammable material. Never use NiCd or NiMH type chargers to charge LiPO batteries. 2. The international transportation of lithium cells and batteries is regulated by the International Civil Aviation Organization (ICAO) Technical Instructions and corresponding International Air Transport Association (IATA) Dangerous Goods Regulations.S. LLC Update: July 1. follow these safety steps: a. Store your batteries in a cool. Venom Power Lithium Polymer Power Cells feature a separate balancing plug that isolates each cell in a pack and charges it independently. 3. Page 11 of 13 Copyright ©2013 Vertical Partners West. . c. Make sure the battery connections are connected in the correct polarity. return the battery pack to normal use with caution. d. After 30 minutes. Immediately remove the battery pack from your model or charger. All rights reserved. dry place between 40-80 Fº / 4-26 Cº. b. 6. Any time you have an accident with your model or if the battery swells “balloons” or if the battery exceeds temperature guidelines. cell damage and fire.Vertical Partners West. Charge each battery pack individually. 4. SECTION 16: Safety During Charging Instructions 1. Refer to the battery label for the proper cell count and charging amperage setting. if the pack appears stable. A wrong connection will damage the battery and may cause a fire. well ventilated area. Charging packs in series may result in improper charger cell recognition and an improper charging rate that may lead to overcharging. Store battery packs out of the reach of children and pets. Selecting a cell count or amperage charge rate other than the one listed on the battery pack will damage the battery and may cause a fire. 8. Observe the battery for 30 minutes from a safe distance. 2. 2013 5. Do not let exposed battery wires touch each other. Never charge battery packs in series. Place the battery in a non-flammable. LLC. The balancing plug can be identified by the multi wire Molex plug. is not swollen and does not show any signs of damage. Always check to make sure that your charger settings match those listed on the battery pack label. This may cause the battery to short and potentially cause a fire. This ensures that all cells peak equally and discharge at the same rate during use preventing one or more cells from discharging past their safe low voltage cut off rating. 9. Do not assemble unmatched or dissimilar LiPO cells. 7. 800mAh Capacity = 5. Check the voltage and follow Step 5 from the Safety Guidlines section. 6.4 Amps b. 2013 5. New LiPO battery packs may require 12 or more charge/discharge cycles before the battery’s optimum performance is reached. All rights reserved.Vertical Partners West.2 Volts per cell. Do not charge at over 1C current. If the battery exceeds the temperature guidelines as above. Do not discharge LiPO batteries below 3. LLC.00 Amps 7. Charge Temp Range: 32 . it is recommended that the battery pack is not discharged over 7C. Example: 1200mAh ÷ 1000 = 1. where 1C= battery pack mAh capacity ÷ 1000. b. C= battery pack mAh capacity ÷ 1000. 9.80 Amps b. During this time.75 Amps Recommended Maximum Discharge Rates During Break-In Period a. If the battery pack appears swollen or damaged. 800mAh Capacity = 0. example: a.20 Amps c. The voltage of a typical LiPO cell at rest is 3.140Fº / 0-60Cº Storage Temp Range: 40 -80Fº / 4-26Cº For optimum performance in cold climates. SECTION 17: Safety During New Battery Break-In 1. 1200mAh Capacity = 1.0 Volts per cell. 7C = 7 x 1C. 2. Please use the following guidelines: a. 2000mAh Capacity = 2. warm to 100Fº/ 37Cº before use. 1200mAh Capacity = 8. Do not peak charge to more than 4. . c. LLC Update: July 1. Example: A 2S Battery Pack contains two cells.7 Volts. Divide the battery mAh capacity by 1000 to determine the proper charge rate. 8.110Fº / 0-43Cº Discharge Temp Range: 32 . Example: [(1250mAh ÷ 1000) x 7] = 8. Always check battery pack voltage before charging. isolate the battery pack and follow Step 5 from the Guidelines & Warnings section.4 Amps c. therefore the peak voltage should not exceed 8. 2000mAh Capacity = 14 Amps Page 12 of 13 Copyright ©2013 Vertical Partners West.4 Volts. Battery Temperature is critical.20 Amps Charge Rate for Venom Power LiPO Battery Packs. DO NOT attempt to charge it. 3.0 Volts. Example for 15c packs: (3200 mAh ÷ 1000) x 15c = 48 Amps b. All rights reserved. Never discharge a LiPO battery pack at more than the manufacturers recommended discharge rate.0 Volts. expressed or implied. the water is now saturated with salt. .Vertical Partners West. re-submerge and re-test until the voltage reads 0. state and country regulations. SECTION 20: Additional Information The information contained herein is based on the data available to us and believed to be correct. 9. Page 13 of 13 Copyright ©2013 Vertical Partners West. LLC Update: July 1. 4. EPA that require special disposal requirements. Example for 20c packs: (2100 mah ÷ 1000) x 20c = 42 Amps SECTION 19: Battery Disposal Instructions 1. 2013 SECTION I8: Safety During Discharging 1. Fill a bucket with enough water to submerge the battery pack completely. Add salt to the water until no more salt will dissolve. If the voltage does not read 0. 5. 6. The discharge rate is: Battery pack capacity (mAh) ÷ 1000 x Pack C rating a. Vertical Partners West. Remove the battery pack from the salt water and test the voltage. 2. Dispose in according to local.S. it is safe to dispose. LLC makes no warranty. 7. Discharge battery pack to 2.0 Volts. 8. These batteries do not contain any materials listed by the U. LLC. Place the battery pack in the bucket and leave submerged in the salt water solution for 24 hours. 2.5 Volts per cell or less. Once the battery pack has been discharged to 0. However. Users should consider the data only as a supplement to other information gathered through personal research and must make independent determinations of the suitability and completeness of information from all sources to ensure the proper use and disposal of these materials and the safety and health of employees and customers.