Samsung GH15LS LCD Monitor Service Manual

March 24, 2018 | Author: videoson | Category: Electrostatic Discharge, Electrical Connector, Force, Technology, Manufactured Goods
Share
Report this link


Comments



Description

TFT-LCD MONITORGH15LS GH15ES GH15MS SERVICE Manual TFT-LCD MONITOR CONTENTS 1. Precautions 2. Product Specifications 3. Disassembly & Reassembly 4. Troubleshooting 5. Exploded View & Parts List GH15LS/GH15ES 6. Electrical Parts List 7. Block Diagram 8. Wiring Diagram 9. Schematic Diagrams 10. Panel Description GH15MS 1 Precautions Follow these safety, servicing and ESD precautions to prevent damage and to protect against potential hazards such as electrical shock. 1-1 Safety Precautions 1-1-1 Warnings 1. For continued safety, do not attempt to modify the circuit board. 2. Disconnect the AC power and DC Power Jack before servicing. 3. (READING SHOULD NOT BE ABOVE 0.5mA) When the chassis is operating, semiconductor heatsinks are potential shock hazards. TEST ALL EXPOSED METAL SURFACES 1-1-2 Servicing the LCD Monitor 1. 2. 1-1-3 Fire and Shock Hazard Before returning the monitor to the user, perform the following safety checks: 1. Inspect each lead dress to make certain that the leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the monitor. 2. Inspect all protective devices such as nonmetallic control knobs, insulating materials, cabinet backs, adjustment and compartment covers or shields, isolation resistor-capacitor networks, mechanical insulators, etc. 3. 2-WIRE CORD When servicing the LCD Monitor, remove the static charge by connecting a 10k ohm resistor in series with an insulated wire (such as a test probe) between the chassis and the anode lead. (Disconnect the AC line cord from the AC outlet.) It is essential that service technicians have an accurate voltage meter available at all times. Check the calibration of this meter periodically. Leakage Current Hot Check (Figure 1-1): WARNING: Do not use an isolation transformer during this test. Use a leakage current tester or a metering system that complies with American National Standards Institute (ANSI C101.1, Leakage Current for Appliances), and Underwriters Laboratories (UL Publication UL1410, 59.7). GH15LS/GH15ES/GH15MS LEAKAGE CURRENT TESTER DEVICE UNDER TEST ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED) EARTH GROUND Figure 1-1. Leakage Current Test Circuit 4. With the unit completely reassembled, plug the AC line cord directly into a 120V AC outlet. With the unit’s AC switch first in the ON position and then OFF, measure the current between a known earth ground (metal water pipe, conduit, etc.) and all exposed metal parts, including: metal cabinets, screwheads and control shafts. The current measured should not exceed 0.5 milliamp. Reverse the power-plug prongs in the AC outlet and repeat the test. 1-1-4 Product Safety Notices Some electrical and mechanical parts have special safety-related characteristics which are often not evident from visual inspection. The protection they give may not be obtained by replacing them with components rated for higher voltage, wattage, etc. Parts that have special safety characteristics are identified by ! on schematics and parts lists. A substitute replacement that does not have the same safety characteristics as the recommended replacement part might create shock, fire and / or other hazards. Product safety is under review continuously and new instructions are issued whenever appropriate. 1-1 1 Precautions 1-2 Servicing Precautions WARNING: An electrolytic capacitor installed with the wrong polarity might explode. Caution: Before servicing units covered by this service manual, read and follow the Safety Precautions section of this manual. Note: If unforeseen circumstances create conflict between the following servicing precautions and any of the safety precautions, always follow the safety precautions. 1-2-1 General Servicing Precautions 1. 2. 3. Always unplug the unit’s AC power cord from the AC power source and disconnect the DC Power Jack before attempting to: (a) remove or reinstall any component or assembly, (b) disconnect PCB plugs or connectors, (c) connect a test component in parallel with an electrolytic capacitor. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such elements to their original position. 4. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). 5. Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON. Connect an insulation resistance meter (500 V) to the blades of the AC plug. The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be greater than 1 megohm. 6. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that the area around the serviced part has not been damaged. Always connect a test instrument’s ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrument’s ground lead last. 1-3 Electrostatically Sensitive Devices (ESD) Precautions Some semiconductor (solid state) devices can be easily damaged by static electricity. Such components are commonly called Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated circuits and some fieldeffect transistors. The following techniques will reduce the incidence of component damage caused by static electricity. 1. Immediately before handling any semiconductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. Alternatively, wear a discharging wriststrap device. To avoid a shock hazard, be sure to remove the wrist strap before applying power to the monitor. 6. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. 7. 2. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of an electrostatic charge. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective material to the chassis or circuit assembly into which the device will be installed. 3. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ESDs. Caution: Be sure no power is applied to the chassis or circuit and observe all other safety precautions. 4. Use only a grounded-tip soldering iron to solder or desolder ESDs. 5. 1-2 Use only an anti-static solder removal device. Some solder removal devices not classified as “anti-static” can generate electrical charges sufficient to damage ESDs. 8. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting your foot from a carpeted floor can generate enough static electricity to damage an ESD. GH15LS/GH15ES/GH15MS 2 Product Specifications 2-1 Specifications Description Item GH15LS/GH15ES GH15MS LCD Panel TFT-LCD panel, RGB vertical stripe, normaly white, 15-Inch viewable, 0.297 (H) pixel pitch Scanning Frequency Horizontal : 30 kHz ~ 61 kHz (Referring ~ Timing chart, Page 2-3, 2-4) Vertical : 50 Hz ~ 75 Hz (Referring ~ Timing chart, Page 2-3, 2-4) Display Colors 16,003,008 colors Maximum Resolution Horizontal : 1024 Pixels Input Video Signal Analog, 0.714 Vp-p ± 5% positive at 75 Ω, internally terminated Input Sync Signal Type: Seperate H/V sync, Composite H/V, Sync-on-Green, automatic synchronization without external switch of sync type Level: TTL level Maximum Pixel Clock rate 80 MHz Active Display Horizontal/Vertical 304.1 mm / 228.1 mm AC power voltage & Frequency AC 90 ~ 264 Volts, 60/50 Hz ~ 12V/3A Power Consumption 25 W (normal) Dimensions Unit (W x D x H) With Simple Stand Without Simple stand With Pivot Stand Vertical : 768 Pixels Without Pivot Stand 15.4 x 15.1 x 6.8 Inches (391.4 x 383.6 x 173 mm) 15.4 x 11.5 x 2.5 Inches (391.4 x 292.8 x 64.0 mm) 15.4 x 15.1 x 6.8 Inches (391.4 x 383.6 x 173 mm) 15.4 x 17.1 x 6.8 Inches (391.4 x 433.6 x 173 mm) 15.4 x 11.5 x 2.5 Inches (391.4 x 292.8 x 64.0 mm) 16.5 x 15.2 x 6.8 Inches (417.9 x 386.1 x 173 mm) 16.5 x 11.7 x 2.5 Inches (417.9 x 297.9 x 64.2 mm) 16.5 x 15.2 x 6.8 Inches (417.9 x 386.1 x 173 mm) 16.5 x 17.2 x 6.8 Inches (417.9 x 436.1 x 173 mm) 16.5 x 11.7 x 2.5 Inches (417.9 x 297.9 x 64.2 mm) Weight (Net/Gross) 4.2 kg (9.3 lbs) / 5.2 kg (11.5 lbs) 4.3 kg (9.5 lbs) / 5.5 kg (12.1 lbs) Environmental Considerations Operating Temperature : 50 °F ~ 104 °F (10 °C ~ 40 °C) Humidity : 10 % ~ 80 % Storage Temperature : 13 °F ~ 113 °F (-25 °C ~ 45 °C) Humidity : 5 % ~ 95 % Audio Characteristics (GH15MS) • Built-in Microphone: High-sensitivity condenser microphone (mono) • Audio input: Left/Right Stereo phone jack, 0.5 Vrms • Sound output: 1.0 W (left) + 1.0 W (right)/THD 1% at 8ohm • Frequency response: 80 Hz~20 kHz (at –3dB) • Headphone: Max 50mW output (3.5-pi jack) • Speaker: Internal semi Dome (16ohm x 2) •GH15LS/GH15ES/GH15MS complies with SWEDAC (MPR II) recommendations for reduced electromagnetic fields. •Designs and specifications are subject to change without prior notice. GH15LS/GH15ES/GH15MS 2-1 2 Product Specifications 2-2 Pin Assignments Sync Type Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 2-2 15-Pin Signal Cable Connector Separate Red Green Blue GND GND (DDC Return) GND-R GND-G GND-B No Connection GND-Sync./Self Test GND DDC Data H-Sync. V-Sync. DDC Clock Composite Red Green Blue GND GND (DDC Return) GND-R GND-G GND-B No Connection GND-Sync./Self Test GND DDC Data H/V-Sync. Not Used DDC Clock Sync-on-green Red Green + H/V Sync. Blue GND GND (DDC Return) GND-R GND-G GND-B Not Used GND-Sync./Self Test GND DDC Data Not Used Not Used DDC Clock GH15LS/GH15ES/GH15MS 2 Product Specifications 2-3 Timing Chart This section of the service manual describes the timing that the computer industry recognizes as standard for computer-generated video signals. Table 2-1. Timing Chart Mode IBM VESA VGA1/70 Hz 640 x 350 VGA2/70 Hz 720 x 400 VGA3/60 Hz 640 x 480 640/72 Hz 640 x 480 640/75 Hz 640 x 480 800/56 Hz 800 x 600 800/60 Hz 800 x 600 fH (kHz) 31.469 31.469 31.469 37.861 37.500 35.156 37.879 A µsec 31.778 31.777 31.778 26.413 26.667 28.444 26.400 B µsec 3.813 3.813 3.813 1.270 2.032 2.000 3.200 C µsec 1.589 1.589 1.589 3.810 3.810 3.556 2.200 D µsec 26.058 26.058 26.058 20.825 20.317 22.222 20.000 E µsec 0.318 0.318 0.318 0.508 0.508 0.667 1.000 fV (Hz) 70.086 70.087 59.940 72.809 75.000 56.250 60.317 O msec 14.268 14.268 16.683 13.735 13.333 17.778 16.579 P msec 0.064 0.064 0.064 0.079 0.080 0.057 0.106 Q msec 1.716 0.858 0.794 0.528 0.427 0.626 0.607 R msec 11.504 13.155 15.761 13.100 12.800 17.067 15.840 S msec 0.985 0.191 0.064 0.026 0.027 0.028 0.026 Clock Frequency (MHz) 25.175 28.322 25.175 31.500 31.500 36.000 40.000 Polarity H.Sync Positive Negative Negative Negative Negative Positive Positive V.Sync Negative Positive Negative Negative Negative Negative Positive Remark Separate Separate Separate Separate Separate Separate Separate Timing Separate Sync Horizontal Vertical Video Video Video Video CC DD E E Q RR Q S S Sync Sync Sync Sync BB PP AA O O A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width C : Back porch D : Active time Q : Back porch R : Active time E : Front porch GH15LS/GH15ES/GH15MS S : Front porch 2-3 2 Product Specifications Table 2-1. Timing Chart (Continued) Mode MAC. VESA 800/72 Hz 800 x 600 800/75 Hz 800 x 600 1024/60Hz 1024x768 1024/70Hz 1024x768 1024/75Hz 1024x768 640/67 Hz 640 x 480 832/75 Hz 832 x 624 fH (kHz) 48.077 46.875 48.363 56.476 60.023 35.000 49.726 A µsec 20.800 21.333 20.677 17.707 16.660 28.571 20.110 B µsec 2.400 1.616 2.092 1.813 1.219 2.116 1.117 C µsec 1.280 3.232 2.462 1.920 2.235 3.175 3.910 D µsec 16.000 16.162 15.754 13.653 13.003 21.164 14.524 E µsec 1.120 0.323 0.369 0.320 0.203 2.116 0.559 fV (Hz) 72.188 75.000 60.004 70.069 75.029 66.667 74.551 O msec 13.853 13.333 16.666 14.272 13.328 15.000 13.414 P msec 0.125 0.064 0.124 0.106 0.050 0.086 0.060 Q msec 0.478 0.448 0.600 0.513 0.466 1.114 0.784 R msec 12.480 12.800 15.880 13.599 12.795 13.714 12.549 S msec 0.770 0.021 0.062 0.053 0.017 0.086 0.020 50.000 49.500 65.000 75.000 78.750 30.240 57.284 Polarity H.Sync Positive Positive Negative Negative Positive Negative Negative V.Sync Positive Positive Negative Negative Positive Negative Negative Remark Separate Separate Separate Separate Separate Separate Separate Timing Clock Frequency (MHz) Separate Sync Horizontal Vertical Video Video Video Video CC DD E E Q RR Q S S Sync Sync Sync Sync BB PP AA O O A : Line time total B : Horizontal sync width O : Frame time total P : Vertical sync width C : Back porch D : Active time Q : Back porch R : Active time E : Front porch 2-4 S : Front porch GH15LS/GH15ES/GH15MS 3 Disassembly and Reassembly This section of the service manual describes the disassembly and reassembly procedures for the GH15LS/GH15ES/GH15MS monitor. WARNING: This monitor contains electrostatically sensitive devices. Use with caution when handling these components. 3-1 Disassembly Cautions:1. Disconnect the monitor from the power source before disassembly. 2. Follow these directions carefully; never use metal instruments to pry apart the cabinet. 3-1-1 Removing the Stand 3-1-3 Standard Stand Disassembly 1. Remove 4 screws in the hinge area. 1. Remove 2 screws from the Stand front. 2. Disconnect Power Cord and Signal Cable. 2. Remove 7 screws from the Stand Bottom. 3. Pry it off the back of the monitor. 3. Remove Stand Rear from the Stand assembly. 4. Remove 5 screws from the Stand assembly. 3-1-2 Main Body Disassembly 5. Remove the Neck front from the Stand assembly. 1. Remove 2 screws on the two corner of the Rear Cover. 6. Remove 2 screws from the Stand assembly. 2. Remove Rear Cover from the Front Cover. 3. Remove 4 screws on the Shield and remove the shield. 7. Remove Neck Rear from the Stand assembly. 8. Remove 4 screws from the Stand assembly. 4. Disconnect Inverter wire, Function PCB wire and Interface wire. Remove 3 screws on the Main PCB and remove 2 screws on the D sub shield. 5. Remove 3 screws on the power PCB and remove 2 screws on the Inverter PCB. 6. Remove the Main PCB Assembly. 7. Remove 3 screws on the Function PCB from locking area of Function knob and remove Function PCB. GH15LS/GH15ES/GH15MS 3-1 3 Disassembly and Reassembly 3-2 Replacement Order of Lamp Assemblies (GH15LS/GH15ES/GH15MS : Samsung Panel) 1. After confirm there is nothing on the disk Turn the LCD module over and put it on a flat desk set to the ground. 2. Push down the stopper and slide the lamp unit. 3. Please take out the lamp unit from the LCD module. 3-2 GH15LS/GH15ES/GH15MS 3 Disassembly and Reassembly 4. Please fix the new lamp units on the LCD module : opposite process 2 and 3 * Replacement of lamp unit should be done at the power off state and recommanded clean bench condition. 3-3 Reassembly Reassembly procedures are in the reverse order of Disassembly procedures. GH15LS/GH15ES/GH15MS 3-3 3 Disassembly and Reassembly Memo 3-4 GH15LS/GH15ES/GH15MS 4 Troubleshooting Notes: 1. Before troubleshooting, setup the PC’s display as below. • Resolution: 1024 x 768 • H-frequency: 48 kHz • V-frequency: 60 Hz 2. If no picture appears, make sure the power cord is correctly connected. 3. Check the following circuits. • No raster appears: Audio PCB, SMPS PCB, Main PCB • 12V develop but no screen: Main PCB • 12V does not develop: Audio PCB, SMPS PCB 4. If you push and hold the “EXIT” button for more than 5 seconds, the monitor automatically turns back to the factory preset. 4-1 No Power (GH15LS/GH15ES/GH15MS) Does proper DC 12 V appear at FT901, FT902 or Pin 1, 2 of CN101? No Check SMPS or CN101. Yes Does proper DC 3.3 V appear at Pin 7 of CN 101? No Check SMPS. Yes Check IC102 and Q192. GH15LS/GH15ES/GH15MS 4-1 4 Troubleshooting 4-2 No Video 1 Does the H-sync pulse appear at Pin 9 of IC108? No Check CN102. Yes 4 Does the H-sync pulse appear at Pin 150 of IC105? No Replace IC108 or check its related circuit. Yes 2 Does the V-sync pulse appeaer at Pin 30 of IC301? No check CN102. Yes 3 Does the V-sync pulse appeaer at Pin 148 of IC105? No Replace IC301 or check its related circuit. No Replace IC105 or check its related circuit. Yes 5 Does the clock pulse appeaer at Pin 44 of IC105? Yes 6 No Do the pulse appeaer at Pin 43 of IC105? Yes 7 Does the waveforms appeaer at Pin 3 and 16 of CN201? No Replace IC251 or check its related circuit. Yes Replace LCD Panel 4-2 GH15LS/GH15ES/GH15MS 4 Troubleshooting WAVEFORMS 1 5 2 6 3 7 4 GH15LS/GH15ES/GH15MS 4-3 4 Troubleshooting 4-3 User Controls Don’t Work Does the DC level change at Pin 35 and 36 of IC301 when you push the front panel button? No Check the buttons. (SW801~SW808) Yes Refer to 4-4 No OSD Display. 4-4 No OSD There is video but no OSD. 5 While pushing a front control button does any pulse appear at Pin 46,47 and 55, 56 and 63,64 of IC105? Yes No 1 3 2 No Do sync signals appear at Pin 44, 150 and 43 of IC105? Yes Replace IC105. Replace IC105 or check its related circuit. Replace IC251 and IC252. Replace IC105 or check its related circuit. Replace CN251. WAVEFORMS 5 4-4 GH15LS/GH15ES/GH15MS 4 Troubleshooting 4-5 No SOUND (GH15MS) Does the DC 12V appear at Pin 15, 16 of IC401 and Pin 5, 6, 7, 8 of Q403? No Check Q403, Q401 and related circuit. Yes Does the sound input signal appear at Pin 4 and 9 of IC401? No Check CN401 and related circuit. Yes Does the sound signal appear at Pin 14 and 17 of IC401? No Check IC401 and related circuit. Yes Check CN402 outputs. GH15LS/GH15ES/GH15MS 4-5 4 Troubleshooting 4-6 Microphones Don’t Work Does the PC’s sound program operate well? No Check the PC’s sound program and compatibility. No Connect the cable between the PC and monitor. No Check the connection between CN808 on the Audio PCB and the Internal Microphone. Yes Is the connection between the PC and monitor secure? Yes Is the Internal Microphone connector attached? Yes Does the Internal Microphone work? No Check Q801 and related circuits. Yes Does the External Microphone work? No Check the CN803 jack. Yes OK 4-7 Headphones Don’t Work Can you hear any sound from the Headphones? No Check CN802 on the Audio PCB and related circuit D805, D806, R811, and R812. Yes OK 4-6 GH15LS/GH15ES/GH15MS 5 Exploded View and Parts List 5-1 GH15LS/GH15ES GH15LS/GH15ES/GH15MS 5-1 5 Exploded View & Parts List 5-2 GH15MS 5-2 GH15LS/GH15ES/GH15MS 6 Electrical Parts List 6-1 Main PCB Parts Loc. No. CIS CIS CIS CIS CIS CN101 CN102 IC301 IC301_SOCK CIS BD181 BD182 BD183 BD201 BD205 BD206 BD301 BD302 BD303 BD304 C101 C102 C103 C104 C105 C106 C112 C131 C132 C133 C134 C135 C136 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155 C156 C157 C159 C160 C161 C162 C163 C164 C165 Code No. BN44-00053A BN72-00209A BN75-00176A BN70-00204A BN71-00024A 3711-004853 3701-001219 0903-001194 3704-001071 BN46-00008L 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2703-001334 2402-000170 2402-001044 2203-000257 2402-000168 2203-000257 2402-000170 2409-001029 2203-000257 2203-000257 2203-000257 2203-000257 2203-000257 2203-000257 2203-005005 2203-005005 2402-000108 2402-000168 2203-005005 2402-000108 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2402-000108 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2402-000108 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2402-000108 GH15LS/GH15ES/GH15MS Description ADAPTOR SUPPORT-POWER UNIT-SHIELD/DSUB SHIELD-D/SUB EARTH-PLATE CONNECTOR-HEADER CONNECTOR-DSUB IC-MICROCONTROLLER SOCKET-IC MICOM-S/W,GOGH INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-ORGANIC C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD Specification DPA30L,150S,100-240VAC,47 - 63 HZ,12VDC/3.3VDC,2A/2A,-,30.6,AC-DC,-10~40C,-,GH15LS,ABS+PC,GR37,-,5V,-,-,GH15LS,-,SPTE T0.5,-,-,-,-,SPTE,-,T0.5,-,-,-,-,GH17LS,SUS,T0.15,-,-,BOX,7P,1R,2MM,ANGLE,SN,WHT 15P,3R,FEMALE,ANGLE,AUF 3P863,8Bit,SDIP,42P,600MIL,12MHz,ST,CMOS,PLASTIC,5V,-,-40to+85C,1040BYTE,48KBYTE 42P,DIP,SN,1.778mm GH15LS,-,-,-,-,-,1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1.5uH,10%,2x1.25x0.85mm 1uF,20%,50V,GP,TP,4.3x4.3x5.4, 100uF,20%,25V,-,TP,8.3x8.3x6.3 10nF,10%,50V,X7R,TP,1608 100uF,20%,16V,GP,TP,8.3x8.3x6.3mm 10nF,10%,50V,X7R,TP,1608 1uF,20%,50V,GP,TP,4.3x4.3x5.4, 120uF,20%,6.3V,WT,TP,10.3x10.3x10.3mm,9 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100uF,20%,16V,GP,TP,8.3x8.3x6.3mm 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 Remarks SNA SNA SNA SNA SNA SNA SNA 6-1 6 Electrical Parts List Loc. No. C166 C167 C168 C169 C170 C171 C172 C173 C187 C188 C189 C211 C215 C216 C217 C223 C227 C228 C229 C230 C232 C301 C302 C303 C304 C311 C312 C313 C371 C372 C373 C374 C375 CN201 CN301 CN302 D131 D132 D133 D301 D302 FT110 FT111 FT112 FT113 FT114 FT901 FT902 FT903 FT904 FT905 FT906 IC102 IC105 IC108 IC251 IC371 IC372 MP1.0 Q102 Q103 6-2 Code No. 2203-000280 2203-000626 2203-000236 2203-000236 2203-000384 2203-000384 2203-000384 2203-000280 2402-000170 2402-000108 2203-000257 2402-000108 2402-000108 2402-000108 2402-000108 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2203-005005 2402-000108 2203-000257 2203-000257 2203-000257 2203-000626 2203-000626 2203-005005 2402-000108 2203-005005 2402-000108 2203-000257 2203-000236 3711-003161 3711-000556 3711-002049 0401-001056 0401-001056 0401-001056 0401-001056 0401-001056 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 3301-001145 1203-001488 1003-001377 0803-000122 1205-001740 1103-001023 1103-001164 BN41-00088A 0501-002080 0501-002080 Description C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP CONNECTOR-HEADER CONNECTOR-HEADER CONNECTOR-HEADER DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD CORE-FERRITE BEAD IC-POSI.FIXED REG. IC-LCD CONTROLLER IC-TTL IC-TRANSMITTER IC-EEPROM IC-EEPROM PCB MAIN TR-SMALL SIGNAL TR-SMALL SIGNAL Specification Remarks 0.01nF,0.5pF,50V,NP0,TP,1608 0.022nF,5%,50V,NP0,TP,1608 0.1nF,5%,50V,NP0,TP,1608 0.1nF,5%,50V,NP0,TP,1608 0.015nF,5%,50V,NP0,TP,1608 0.015nF,5%,50V,NP0,TP,1608 0.015nF,5%,50V,NP0,TP,1608 0.01nF,0.5pF,50V,NP0,TP,1608 1uF,20%,50V,GP,TP,4.3x4.3x5.4, 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 10nF,10%,50V,X7R,TP,1608 0.022nF,5%,50V,NP0,TP,1608 0.022nF,5%,50V,NP0,TP,1608 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,10%,16V,X7R,TP,1608 10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,1608 0.1nF,5%,50V,NP0,TP,1608 BOX,20P,1R,1.25mm,ANGLE,SN BOX,12P,1R,1.25mm,SMD-A,SN BOX,6P,1R,1.25mm,SMD-A,SN MMBD4148SE,75V,200MA,SOT-23,TP MMBD4148SE,75V,200MA,SOT-23,TP MMBD4148SE,75V,200MA,SOT-23,TP MMBD4148SE,75V,200MA,SOT-23,TP MMBD4148SE,75V,200MA,SOT-23,TP AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,7805,T0-252,3P,-,PLASTIC,4.8/5 GMZAN1,QFP,160P,1102MIL,SINGLE,-,TR,PLASTIC,3.47V,0TO+70C,1.8W,-,LCD CONTROLLER 74F125,BUFFER,SOP,14P,150MIL,Q DS90C385,TSSOP,56P,240MIL,PLASTIC,4V,1.63W,-10 TO +70C,ST,FPD LINK-85MHZ(LVDS) 524C80D81,1028x8Bit,SOP,8P,150MIL,10mS,5V,10%,PLASTIC,0to+70C,110uA,CMOS,TP 24LC21A,128X8BIT,SOP,8P,150MIL,-,5V,10%,PLASTIC,0 TO +70C,100UA,CMOS,TP GH15L/M,FR-4,4,-,1.6,120*110*1.6,-,-,-,2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA SNA GH15LS/GH15ES/GH15MS 6 Electrical Parts List Loc. No. Q104 Q105 Q106 Q107 Q311 Q312 R102 R104 R106 R107 R108 R109 R110 R113 R114 R115 R117 R118 R119 R120 R121 R122 R123 R124 R125 R185 R186 R187 R188 R189 R190 R203 R204 R205 R207 R301 R314 R316 R317 R320 R321 R322 R323 R324 R325 R326 R327 R329 R330 R334 R335 R336 R337 R338 R339 R340 R341 R343 R344 R345 R346 Code No. 0501-002080 0501-002080 0501-002080 0501-002080 0501-002080 0501-002080 2007-000090 2007-000102 2007-000102 2007-000090 2007-000078 2007-000090 2007-000090 2007-001167 2007-000074 2007-001167 2007-000072 2007-000072 2007-000072 2007-000074 2007-000074 2007-000074 2007-001167 2007-001167 2007-001167 2007-000102 2007-000090 2007-000084 2007-000090 2007-000084 2007-000090 2007-000074 2007-000074 2007-000070 2007-000070 2007-000078 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000109 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000084 2007-000084 2007-000084 2007-000084 2007-000084 2007-000084 2007-000084 GH15LS/GH15ES/GH15MS Description TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP Specification Remarks 2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 2SC2412K,NPN,200mW,SC-59,TP,120-270 10KOHM,5%,1/16W,DA,TP,1608 100Kohm,5%,1/16W,DA,TP,1608 100Kohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 75ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 75ohm,5%,1/16W,DA,TP,1608 47ohm,5%,1/16W,DA,TP,1608 47ohm,5%,1/16W,DA,TP,1608 47ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 75ohm,5%,1/16W,DA,TP,1608 75ohm,5%,1/16W,DA,TP,1608 75ohm,5%,1/16W,DA,TP,1608 100Kohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 0ohm,5%,1/16W,DA,TP,1608 0ohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 1Mohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 4.7Kohm,5%,1/16W,DA,TP,1608 6-3 6 Electrical Parts List Loc. No. R347 R348 R349 R350 R351 R362 R371 R372 R373 R374 R375 R376 R377 R378 R381 R901 R902 R903 R904 R905 R910 R911 R912 R913 R918 R919 R973 R974 R975 R976 RA130 RA131 RA132 RA133 RA134 RA136 RA137 RC201 RC202 RC203 RC204 RC205 RC206 RC207 X100 X311 ZD181 ZD182 ZD183 ZD184 ZD185 6-4 Code No. 2007-000084 2007-000078 2007-000075 2007-000077 2007-000120 2007-000090 2007-000074 2007-000074 2007-000092 2007-000092 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000074 2007-000078 2007-000078 2007-000078 2007-000078 2007-000078 2007-000092 2007-000070 2007-000075 2007-000120 2007-000090 2007-000090 2011-000002 2011-000002 2011-000002 2011-000002 2011-000002 2011-000002 2011-000002 2503-001018 2503-001018 2503-001018 2503-001018 2503-001018 2503-001018 2503-001018 2801-003755 2801-003773 0403-000579 0403-000579 0403-000579 0403-000579 0403-000579 Description R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK R-NETWORK C-NETWORK C-NETWORK C-NETWORK C-NETWORK C-NETWORK C-NETWORK C-NETWORK CRYSTAL-SMD CRYSTAL-SMD DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER Specification Remarks 4.7Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 220ohm,5%,1/16W,DA,TP,1608 470ohm,5%,1/16W,DA,TP,1608 680ohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 15Kohm,5%,1/16W,DA,TP,1608 15Kohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 15Kohm,5%,1/16W,DA,TP,1608 0ohm,5%,1/16W,DA,TP,1608 220ohm,5%,1/16W,DA,TP,1608 680ohm,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 10KOHM,5%,1/16W,DA,TP,1608 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 22ohm,5%,63mW,L,CHIP,8P,TP 15PFX4,10%,50V,15PFX4,10%,50V,15PFX4,10%,50V,15PFX4,10%,50V,15PFX4,10%,50V,15PFX4,10%,50V,15PFX4,10%,50V,20MHZ,30PPM,28-AAN,20PF,50OHM,TP 12MHZ,30PPM,28-AAN,20PF,50OHM,TP BZX84C5V1,5.1V,5%,200mW,SOT-23 BZX84C5V1,5.1V,5%,200mW,SOT-23 BZX84C5V1,5.1V,5%,200mW,SOT-23 BZX84C5V1,5.1V,5%,200mW,SOT-23 BZX84C5V1,5.1V,5%,200mW,SOT-23 GH15LS/GH15ES/GH15MS 6 Electrical Parts List 6-2 Others Loc. No. Code No. Description Specification Remarks - BN95-00225A BN95-00234A BN95-00254A ASSY MANUAL ASSY MANUAL ASSY MANUAL GH15LS,-,-,GH15MS,-,-,GH15ES,-,-,- GH15LS GH5MS GH15ES CIS CIS CIS M/PCB+PAN IN/PCB+M/PCB CIS - BN07-00026A BN44-00056A BN44-00053A BN39-00036A BN39-00161A BN39-00114A BN59-00167A LCD INVERTER ADAPTOR CBF-HARNESS CBF HARNESS CBF SIGNAL PBA SUB-FUNCTION LTM150XH-L01,CZB,8BIT,331.6*254.76*12.5,16.19M,-,0.297*0.297,-,-,AMLCD/1 LVDS,GOGH,SIC1542,48KHZ,12VDC,1.5MARMS,5.6MARMS,48KHZ,37*140*16.0,4LAMP,40~56KV,-,SIC DPA30L,150S,100-240VAC,47 - 63 HZ,12VDC/3.3VDC,2A/2A,-,30.6,AC-DC,-10~40C,-,20P,150MM,BLU/GRY/WHT,UL1571,AWG30,DF14-20S-1.25C GH15LS,UL/CSA,UL1061#28,12P/12P,160MM,WHT,AWG28,51021-1200,51021-1200,-,-,1.25MM NL15MO,15P/15P,2990,1830MM,UL2990,IVORY,D-SUB/MALE,-,-,GH15MS,GH15_FUNCTION,-,-,-,-,- CIS CIS BN59-00168A BN59-00169A BN59-00169B PBA SUB-PHONE SPEAKER SYSTEM SPEAKER SYSTEM GH15MS,GH15_PHONE,-,-,-,-,GH15MS,-,-,-,-,-,-,-,RIGHT GH15MS,-,-,-,-,-,-,-,LEFT GH15LS/ES/MS GH15LS/ES/MS GH15LS/ES/MS GH15LS/ES/MS GH15LS/ES/MS GH15LS/ES/MS GH15LS/ES/MS GH15MS GH15MS GH15MS 6-3-1 Different Part List (GH15ES) Location C190 C191 C192 C193 C194 IC109 R192 R193 R195 Code 2203-000236 2402-000108 2203-000257 2203-005005 2203-000257 1204-000292 2007-000074 2007-001114 2007-000076 GH15LS/GH15ES/GH15MS Spec. C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP IC-VIDEO SYSTEM R-CHIP R-CHIP R-CHIP Desc. 100pF,5%,50V,NPO,TP,1608,10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,1608,100nF,15%,16V,W5R,TP,1608,1.6m 10nF,10%,50V,X7R,TP,1608,IC-VIDEO,LM1881M,SOP,8P,150MIL 100ohm,5%,1/16W,DA,TP,1608 680Kohm,5%,1/16W,DA,TP,1608 330ohm,5%,1/16W,DA,TP,1608 6-5 6 Electrical Parts List 6-3-2 Different Part List (GH15MS) Location C190 C191 C192 C193 C194 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C412 C416 C420 CN401 CN402 FT401 FT402 IC109 IC401 Q401 Q403 R192 R193 R195 R361 R380 R401 R402 R403 R404 R405 R406 R412 R413 R414 ZD401 ZD402 6-6 Code 2203-000236 2402-000108 2203-000257 2203-005005 2203-000257 2203-005015 2203-005015 2203-000236 2203-000236 2402-000168 2402-000108 2203-005005 2203-005005 2402-000168 2401-001363 2401-001363 2402-000179 2402-000147 3711-004270 3711-004386 3301-001145 3301-001145 1204-000292 1204-001833 0501-002080 0505-000275 2007-000074 2007-001114 2007-000076 2007-000090 2007-000078 2007-000074 2007-000074 2007-000074 2007-000074 2007-000078 2007-000090 2007-000102 2007-000102 2007-000090 0403-001052 0403-001052 Spec. C-CERAMIC,CHIP C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-AL,SMD C-CERAMIC,CHIP C-CERAMIC,CHIP C-AL,SMD C-AL C-AL C-AL,SMD C-AL,SMD CONNECTOR-HEADER CONNECTOR-HEADER CORE-FERRITE BEAD CORE-FERRITE BEAD IC-VIDEO SYSTEM IC-VOLUME CONTROL TR-SMALL SIGNAL FET-SILICON R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP DIODE-ZENER DIODE-ZENER Desc. 100pF,5%,50V,NPO,TP,1608,10uF,20%,16V,WT,TP,4.3x4.3x5.4 10nF,10%,50V,X7R,TP,1608,100nF,15%,16V,W5R,TP,1608,1.6m 10nF,10%,50V,X7R,TP,1608,150nF,+80-20%,16V,Y5V,TP,1608 150nF,+80-20%,16V,Y5V,TP,1608 100pF,5%,50V,NPO,TP,1608,100pF,5%,50V,NPO,TP,1608,100uF,20%,16V,-,8.3x8.3x6.2mm, 10uF,20%,16V,WT,TP,4.3x4.3x5.4 100nF,15%,16V,W5R,TP,1608,1.6m 100nF,15%,16V,W5R,TP,1608,1.6m 100uF,20%,16V,-,8.3x8.3x6.2mm, 470uF,20%,16V,GP,10x12.5mm,5mm 470uF,20%,16V,GP,10x12.5mm,5mm 47uF,20%,16V,GP,TP,6.3x5.4 33uF,20%,25V,-,TP,6.3x5.2,BOX,2P,1R,2MM,ANGLE,SN BOX,3P,1R,2mm,ANGLE,SN AB,4.5x1.6x1.6mm,-,AB,4.5x1.6x1.6mm,-,IC-VIDEO,LM1881M,SOP,8P,150MIL TDA7496L,DIP,20P,-,PLASTIC,26V 2SC2412K,NPN,200mW,SOT-23,TP,1 SI4435DY,P,-30V,+-8.0A,0.02ohm 100ohm,5%,1/16W,DA,TP,1608 680Kohm,5%,1/16W,DA,TP,1608 330ohm,5%,1/16W,DA,TP,1608 10Kohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 100ohm,5%,1/16W,DA,TP,1608 1Kohm,5%,1/16W,DA,TP,1608 10Kohm,5%,1/16W,DA,TP,1608 100Kohm,5%,1/16W,DA,TP,1608 100Kohm,5%,1/16W,DA,TP,1608 10Kohm,5%,1/16W,DA,TP,1608 RD8.2MB,8.2V,7.7-8.64V,200mW,S RD8.2MB,8.2V,7.7-8.64V,200mW,S GH15LS/GH15ES/GH15MS 7 Block Diagram GH15LS/GH15ES/GH15MS 7-1 7 Block Diagrams Memo 7-2 GH15LS/GH15ES/GH15MS 8 Wiring Diagram GH15LS/GH15ES/GH15MS 8-1 8 Wiring Diagram Memo 8-2 GH15LS/GH15ES/GH15MS 9 Schematic Diagrams 9-1 Main Part Schematic diagram (GH15LS/GH15ES/GH15MS) 7 +3.3V_S For Japanese OSD 1.5uH 1.5uH BD206 C229 100nF 16V MO 7 5 3 1 7 5 3 1 8 6 4 2 8 6 4 2 RC201 RC202 SUPLECODE SUPLECODE C215 10uF C216 10uF C227 100nF 16V MO C228 100nF 16V MO 1 16 2 15 3 4 14 13 12 5 1 6 11 7 2 A 125 124 123 122 121 C185 33pF 1/16W 3 1 7 5 3 1 7 5 3 1 7 5 4 2 8 6 4 2 8 6 4 2 8 6 3 1 7 5 3 1 2 8 6 4 2 C147 100nF 16V C146 C145 100nF 16V 100nF 16V +5V_FE IC108 C N74F125D 14 1A N 13 2 M 12 B 3 L 11 C 4 K 10 D 5E J 9 6 F I 7 8 H G B IN 50V MO 10nF C131 R190 10K 1/16W PC_RED_IN 1/16W E IN IN IN 10nF 50V MO IN IN 50VMO 10nF C132 1 U22 50V MO 10nF C133 1 PC_GREEN_IN R118 100 1/16W HSYNC_PLL PC_HSYNC_IN PC_BLUE_IN R119 100 R120 100 50VMO 10nF 1/16W C134 R121 100 50V MO 10nF 1/16W C135 100 50VMO C170 C171 C172 15pF 50V MO 15pF 50V MO 15pF 50V MO 3 1/16W C R123 75 B 2 R125 75 R124 75 1 A 3 C 2 B 1 A 3 C 2 B 1 A 1 R191 0 1/16W SOG_ZAN1 1/16W R122 C150 100nF C151 100nF C152 100nF C153 100nF C154 100nF C155 100nF C156 100nF 16V 16V 16V 16V 16V 16V 16V SOG_CSYNC +3.3V_S C190 100pF 50V 1 +5V_FE R192 100 1/16W A MO IC109 LM1881M C191 C192 10uF 16V 10nF 50V MO R193 680K 1/16W C193 100nF 16V MO PHS PVS EB(2) C189 C188 10uF 16V IN U21 EB(6) EB(3) R188 10K 1/16W +5V_FE Q106 2SC2412K-Q SOG R117 100 EB(0) 8 1 7 2 6 3 5 4 PC_GREEN_IN C194 10nF 50V MO C157 10uF EG(0) C159 100nF 16V EG(7) EG(6) C160 100nF 16V C161 100nF 16V C162 100nF 16V C163 100nF 16V R195 330 1/16W GH15ES/GH15MS only 16V EG(1) EG(7:0) SW_REG_EN B 1/16W U20 1 Q107 2SC2412K-Q C E EB(7) EB(4) ZD185 4.7K 1/16W C149 10uF 16V C165 10uF 16V EB(5) ZD184 R189 4.7K HDATA1 HDATA2 HCLK HDATA3 RESETn HDATA0 HFS R102 10K EB(1) EB(7:0) ZD183 FT114 BLM41P600S RA130 RA131 RA132 R115 75 RA133 22pF 50V MO 4 1 1 100nF 16V 2 5 6 RA134 8 ZD182 ZD181 R187 C148 SOG_ZAN1 B 7 C168 100pF 50V MO 100pF 50V MO TP926 OSD_SDA OSD_SCL R182 100 R976 10K U71 1 DDC_SCL 1 +5V_FE U72 C167 PC_VSYNC_IN 1 TP75 1.5uH 50V MO FT113 BLM41P600S 1 100 BD183 1 C169 SCL 33pF 50V MO TP84 8 SDA OSD_IC R114 1 7 +3.3V_S 10nF C136 DEN DHCLK PC_HSYNC_IN 1 TP74 6 R181 1/16W 100 A123 A122 A121 129 128 127 126 A127 A126 A125 A124 134 133 132 131 130 A132 A131 A130 A129 A128 138 137 136 135 A136 A135 A134 A133 143 142 141 140 139 A141 A140 A139 A138 A137 148 147 146 145 144 gmZAN1 6 75 MMBD4148SE C230 100nF 16V MO RA137 120 A120 119 A119 118 A118 117 A117 116 A116 115 A115 114 A114 113 A113 112 A112 111 A11 110 A110 109 A109 108 A108 107 A107 106 A106 105 A105 104 A104 103 A103 102 A102 101 A101 100 A100 99 A99 98 A98 97 A97 96 A96 95 A95 94 A94 93 A93 92 A92 91 A91 90 A90 89 A89 88 A88 87 A87 86 A86 85 A85 84 A84 83 A83 82 A82 81 A81 IC105 A41 41 A42 42 A43 C223 100nF 16V MO 10 4 1 C211 10uF BD205 1 7 8 5 +3.3V_S 6 3 BD201 1.5uH +3.3V_S TP499 (Vsync) 9 RA136 TP501 R113 1 15 8 1 6 +3.3V_S 1 4 5 8 TP500 7 0 1/16W B B 1 DDC_SDA TP73 TP924 14 R183 22 1/16W D131 1 R180 22 1/16W MO 2 1 TP921 A 1 C184 15pF 50V B 1 SOURCE_PC 1 3 D132 1 3 GND MMBD4148SE 1 TP71 TP72 1 13 B D133 1 1.5uH 1 TP81 10 OSD_CLK G OSD S/W MMBD4148SE 1 3 R201 0 1/16W 1 A1 2 A2 3 A3 4 A4 5 A5 6 A6 7 A7 8 A8 9 A9 10 A10 11 A11 12 A12 13 A13 14 A14 15 A15 16 A16 17 A17 18 A18 19 A19 20 A20 21 A21 22 A22 23 A23 24 A24 25 A25 26 A26 27 A27 28 A28 29 A29 30 A30 31 A31 32 A32 33 A33 34 A34 35 A35 36 A36 37 A37 38 A38 39 A39 40 A40 2 R202 Y 1.5uH 9 2 5 C186 R184 1K 1/16W 80 1 29 GND4 1/16W A146 A145 A144 A143 A142 3 2 1 152 151 150 149 34 33 32 31 30 4 BD181 BD182 1 4 (Hsync) A76 A77 A78 A79 A80 R204 100 1/16W PVS R203 100 PLLGND1 PWRDWN TXCLKIN TXIN26 25 TXIN23 26 VCC2 27 TXIN24 28 TXIN25 8 7 6 5 4 71 A72 72 A73 73 A74 74 A75 EB(5) 39 38 37 36 35 R +3.3V_S 16V 1/16W 75 76 77 78 79 EB(4) PHS TXOUT3TXOUT3+ LVDSGND2 PLLGND PLLVCC R208 0 A67 A68 A69 A70 A71 EB(3) PC_HSYNC_IN 66 67 68 69 70 EB(2) 12 11 10 9 C138 100nF 16V 1/16W 62 A63 63 A64 64 A65 65 A66 EB(1) 43 42 41 40 R207 0 A58 A59 A60 A61 A62 EB(7) 17 16 15 14 13 57 58 59 60 61 16 TXIN16 17 R_FB 18 TXIN17 19 TXIN18 20 TXIN19 21 GND3 22 TXIN20 23 TXIN21 24 TXIN22 EB(6) EB(7:0) TXOUT0+ TXOUT1TXOUT1+ LVDSVCC LVDSGND1 TXOUT2TXOUT2+ TXCLKOUTTXCLKOUT+ C137 100nF 16V C139 10uF BLM41P600S A150 A149 A148 A147 EB(0) ER(6) 48 47 46 45 44 A TP80 1 CN102 d_sub15p 2 12 50V MO FT112 48 A49 49 A50 50 A51 51 A52 EG(5) ER(0) C182 100nF 16V MO IC107 MTV121P-31 C173 0.01nF C166 0.01nF 50V MO 16V VSYNC_OUT HSYNC_PLL A155 A154 A153 A152 A151 EG(4) A 1 EG(3) slcon22p_1 CN201 160 159 158 EG(7) LVDSGND TXOUT0- Q1 PC_BLUE_IN 1 IC106 NC7SZ04P5X 5 VCC NC1 AS-20.000-20-FUND-SMD 1 22 21 20 19 18 16V MO 11 100nF 16V TP925 MO ER(1) C181 100nF 16V MO X100 Q0 A159 A158 A157 A156 EG(6) 1 C144 100nF A160 EG(2) C232 100nF 16V C217 10uF ER(2) 1 EG(7:0) ER(4) ER(3) 52 51 50 49 TXIN1 TXIN0 TXIN27 6 TXIN8 7 TXIN9 8 TXIN10 9 VCC1 10 TXIN11 11 TXIN12 12 TXIN13 13 GND2 14 TXIN14 15 TXIN15 EG(1) 56 55 54 53 TXIN4 TXIN3 TXIN2 GND5 TP375 C142 10uF 16V C180 100nF C143 TP275 TP274 TP273 TP272 EG(0) TP279 TP278 TP277 TP276 ER(5) 1 TP281 TP280 1 VCC 2 TXIN5 3 TXIN6 4 TXIN7 5 GND1 ER(7) 4 TP920 IC251 DS90C385MTD C183 10uF 16V 1 2 ER(7:0) TP918 TP378 FT111 BLM41P600S PC_GREEN_IN 1 2 1 3 +3.3V_PANEL TP78 U59 2 LVDS_EN PC_RED_IN 1 VCC B A 1/16W 157 156 155 154 153 R206 0 BLM41P600S 43 A44 44 A45 45 A46 46 A47 47 A48 1/16W C141 100nF 16V C140 100uF 16V FT110 R205 0 52 A53 53 A54 54 A55 55 A56 56 A57 DHCLK DEN C164 100nF 16V EG(5) EG(4) EG(3) EG(2) ER(7:0) ER(1) ER(0) ER(7) ER(6) ER(5) ER(4) ER(3) ER(2) 7 5 5 3 1 7 5 3 1 7 5 3 1 4 2 8 6 4 2 8 6 4 2 7 5 8 6 3 1 7 5 3 1 2 8 6 4 2 VCC 8 6 RC203 RC204 RC205 SUPLECODE SUPLECODE SUPLECODE 4 VCC VCC VCC VCC VCC VCC RC207 RC206 SUPLECODE SUPLECODE R361 1 2 TP310 BRIGHT 1 1 C301 10uF 3 16V 4 VCC 5 TP901 TP311 1 6 +5V_Touch 7 TP929 BL_EN 1 1 TP902 CN304 Q193 SI9933ADY-T1 TP904 1 R185 100K 1/16W 1 2 3 4 S1 G1 D1 D1_1 D2 S2 G2 D2_1 VCC 1 8 7 6 5 2 TP931 1/16W 13 1/16W R109 10K VCC +3.3V_IN D4 8 TP312 TP313 TP314 1 1 1 2 BD301 1.5uH BD302 1.5uH TP319 BD303 1.5uH TP318 1 KEY1 LED_R KEY2 1 1 4 C106 R106 1uF 100K 1/16W 1 S1 2 S2 3 S3 4 G1 D1 D2 D3 D4 5 6 7 8 TP936 TP53 6 3 1 3 D301 D302 R316 100 U53 R317 100 U54 R916 100 U66 R917 100 B Q102 2SC2412K-Q 4.7K 4.7K R344 38 6 37 7 36 R326 100 TP349 1 8 35 R327 100 TP350 1 9 34 10 33 11 32 12 31 R329 100 TP352 1 13 30 R330 100 TP353 1 14 29 R381 100 TP332 1 U64 15 28 U63 TP337 1 16 TP338 1 R918 TP339 1 R320 100 R321 100 E Q103 2SC2412K-Q 680 1/16W LED_G 1 U4 R974 680 1/16W 1/16W 15K R322 U55 1 U62 1 1K 1 U61 C311 2 27 TP344 1 26 R334 100 25 R335 100 TP345 1 19 24 R336 100 TP346 1 20 23 R337 100 21 22 R338 100 TP347 1 TP348 1 Q1 C313 100nF 16V MO C312 22pF 50V MO E SOG_CSYNC PC_HSYNC_IN PC_VSYNC_IN VSYNC_OUT 18 X311 HC-49/S-SMD(12MHz,30ppm) 22pF 50V MO U3 AUDIO_MUTE KEY1 KEY2 U67 R323 Q0 R348 1K SOURCE_PC 1 1/16W R380 100 1 Q312 2SC2412K-Q B 1 17 1 7 2 1 SWITCH_OFF_N HCLK HFS M_SDA M_SCL VCC VCC VCC 2 1 TP316 BD304 1.5uH 1 LED_G C371 10uF 16V C372 100nF 16V MO C374 10nF 50V MO 10uF TP356 1 C304 10nF 50V MO 16V R373 15K 1/16W R374 15K 1/16W TP357 1 IC371 M24C08-WMN1T 1 2 3 4 8 7 6 R371 100 5 TP362 1 R379 M_SCL M_SDA R977 0 1/16W DDC_SDA DDC_SCL TP358 1 1/16W 0 TP361 1 R372 100 GH15LS/GH15ES/GH15MS 100 39 5 C373 B R107 R351 U2 1 C303 C302 10nF 10nF 50V 50V MO MO TP937 C 1 10K E R345 4.7K R343 1 R325 4 8 PANEL_EN C 1 TP367 1 TP366 1M 1/16W TP317 5 TP51 R975 10K 40 6.3V 1 1 1 U65 VCC PANEL_EN BRIGHT AUDIO_VOLUME +3.3V_PANEL SI4435DY Q191 U49 U24 1 1 1 DDC_SDA DDC_SCL E +3.3V_S C112 120uF SW_REG_EN 1 1 14 1 5 6 7 3 TP368 1 TP334 SW_REG_ENB 3 U26 1 TP330 1 Q104 2SC2412K-Q B SI4435DY Q192 1/16W 100 100 1 CN302 slcon8p D1 D2 D3 100 R903 R904 TP329 1 VCC +3.3V_IN R902 U70 1 VCC C 1 41 TP933 R919 0 1/16W R104 100K 1 TP903 1 12 1K R108 TP86 1 S1 2 S2 3 S3 4 G1 100 1 11 SW_REG_EN E C101 1uF R901 U69 TP333 1 Q105 2SC2412K-Q B R186 10K U68 2 R350 470 1/16W C 1 1 10 TP953 TP315 C SWITCH_OFF_N 1 9 100 1 R110 10K TP938 C187 1uF 50V +12V_INV 1 8 slcon2p R378 R905 1K 1/16W SW_REG_EN R339 +5V_Touch +5V_FE U60 100 R346 VCC 1K R913 1/16W A 1 A A BLM41P600S 1 R324 R341 SW_REG_ENB 1 TP952 FT906 R301 1K 1/16W TP305 42 4.7K 1 1 TP369 1 R340 2 TP950 KS88P6232N 100 4.7K 1 BL_EN SOG HDATA0 HDATA1 HDATA2 HDATA3 LVDS_EN RESETn OSD_SDA OSD_SCL R314 R347 TP951 7 Q311 2SC2412K-Q E IC301 CN301 slcon14p_1 1 1 1 BLM41P600S 1 6 TP944 TP946 BLM41P600S TP948 4.7K 2 2 TP949 FT905 VCC C B 1 BLM41P600S 4.7K 16V 1 5 TP942 BLM41P600S A 25V C104 100uF TP947 B C102 100uF C105 10nF 50V MO B C103 10nF 50V MO FT904 R973 220 LED_R R362 10K 4.7K 1 4 FT902 FT903 1 B 2 TP945 1 1 A TP943 3 1 1 2 A 2 TP941 1 TP940 BLM41P600S 1 1 B 1 1 TP910 OUT GND 2 IN B 1 FT901 B IC102 BA17805FP TP909 TP939 1 CN101 slcon7p 1K R912 1/16W 1K R910 1/16W +3.3V_IN 1K R911 1/16W +12V_IN +12V_INV 1/16W 1/16W R349 220 10K +12V_IN VCC 1 2 3 4 NC_1 NC_2 VCC WC_ NC_3 SCL VSS SDA 8 7 6 5 IC372 24LC21AT-/SN R375 100 R376 100 TP359 1 R377 100 TP360 1 PC_VSYNC_IN C375 100pF 50V MO 9-1 9 Schematic Diagrams 1 2 3 5 6 7 9-2 4 GH15LS/GH15ES/GH15MS 9 Schematic Diagrams 9-2 Audio Part Schematic diagram (GH15MS only) +12V_IN VCC +12V_AUDIO Q403 SI4435DY U28 1 U41 FT401 A 1 R415 100K 1/16W 1 U17 BLM41P600S 1 R412 100K TP22 1/16W FT402 2 R413 100K 1/16W SW_REG_EN A U50 1 1 R417 10K 1 B 1 BLM41P600S R416 100 AUDIO_STANDBY C B E Q402 2SC2412K-Q 1 U23 U18 U19 1 U40 5 6 7 8 1 D1 D2 D3 D4 B S1 S2 S3 G1 2 1 2 3 4 C420 33uF AGND U27 BL_EN U25 1 1 R414 10K C B E Q401 2SC2412K-Q +12V_AUDIO C407 100nF 16V C408 100nF 16V C409 100uF 16V AGND CN401 slcon2p 1 U29 TP913 1 1 U30 R401 100 1 U32 U31 R403 100 1 9 1 TP914 2 INR VS0 VS1 VAROUT_R C401 150nF 16V MO 1 GND0 2 GND1 3 GND2 13 GND3 20 GND4 19 GND5 18 GND6 U33 1 U34 R402 100 U35 1 C404 100pF 50V MO C411 100nF 16V 4 1 OUTL 1 17 1 AGND 10 SVR 6 AGND AGND AGND C415 100nF 16V C414 100nF 16V AGND VAROUT_L 5 AGND AGND 3 TP912 C413 100nF 16V N_C INL C405 100uF 16V ZD402 1 2 1 IC401 VOLUME ZD401 1 TP911 U57 U37 1 CN402 slcon3p 1 C412 470uF 16V AGND U47 8 C402 150nF 16V MO C403 100pF 50V MO 1 U45 U36 R404 100 1 14 OUTR 11 STBY 12 MUTE TDA7496L 1 C410 470uF 16V U43 16 15 7 AGND AGNDAGND R405 1K 1/16W U38 1 AUDIO_VOLUME C406 10uF 16V AGND AUDIO_MUTE AUDIO_STANDBY R978 6.8K 1/16W C416 47uF AGND GH15LS/GH15ES/GH15MS R406 10K AGND AGND R407 10K AGND 9-3 9 Schematic Diagrams Memo 9-4 GH15LS/GH15ES/GH15MS Samsung Electronics Co.,Ltd. 416, Maetan-3Dong, Paldal-Gu, Suwon City, Kyungki-Do, Korea. Printed in Korea P/N : BN68-00225A-00 http://www.samsungmonitor.com (SyncMaster Worldwide) http://www.samsung-monitor.com (SyncMaster USA) http://www.sec.co.kr/monitor (Korea)
Copyright © 2024 DOKUMEN.SITE Inc.