Generac Mobile Products Manual Parts Light Towers MLT4060 80

March 25, 2018 | Author: ahmedsaid85 | Category: Electrical Connector, Trailer (Vehicle), Screw, Manufactured Goods, Mechanical Engineering
Share
Report this link


Comments



Description

DIESEL LIGHT TOWERMLT4060K • MLT4060M MLT4080K • MLT4080M 01447 PARTS MANUAL 13956 D 05/15 CALIFORNIA PROPOSITION 65 WARNING: Diesel engine exhaust and some of its constituents are known to the state of California to cause cancer, birth defects, and other reproductive harm. CALIFORNIA PROPOSITION 65 WARNING: This product contains or emits chemicals known to the state of California to cause cancer, birth defects, and other reproductive harm. ii Introduction This parts manual was prepared based on the information available at the time of publication and is subject to change without notice. Generac Mobile Products reserves the right to change parts at any time. To check whether a revised parts manual is available, contact Generac Mobile Products. DO NOT MODIFY or use this equipment for any application other than which it was designed for. To keep your equipment fully operational, it is suggested you maintain a stock of commonly used maintenance or service parts. A recommended spare parts list can be found in the back of this manual. To order service parts, please go www.generacmobile.com or call Generac Mobile Products. WARNING Before operating or servicing this equipment, read and understand the Generac Mobile Products Operating Manual which was included with the unit when shipped from the factory. Failure to do so increases the risk of injury to yourself or others. GENERAC MOBILE PRODUCTS LLC 215 Power Drive • Berlin, WI 54923 U.S.A. Phone: 920-361-4442 FAX: 920-361-4416 Toll Free: 1-800-926-9768 www.generacmobile.com For technical or parts QUESTIONS, please contact the Generac Mobile Products Customer Support or Technical Support team at 1-800-926-9768. Engine Make:__________________________________________ Engine Serial Number:___________________________________ Engine Model Number: __________________________________ Generator Make: _______________________________________ Generator Model Number: ________________________________ Generator Serial Number: ________________________________ Unit Model Number:_____________________________________ Unit Serial Number: _____________________________________ iii This Page Intentionally Left Blank iv . ............................................................ 38 Engine Assembly ....... 52 Recommended Spare Parts List (2 of 2) ......................................................................................... 46 Trailer ........................................................MLT4080K.......................................................... 40 Generator Assembly .... 28 Cooling System Assembly .................................................MLT4060K........ MLT4080M .................................... 42 Fuel Tank and Ballast Boxes to Unit .........................................................................................................................Jack and Hitch Options ............................................................Mitsubishi Left Side .......... Rear and Top.........Hard Wired Lights......................................................................... 32 Engine Assembly .............................. 8 Mast Junction Box Assembly ....................................................................................................................................Kubota Right Side......................................................... 10 Mast Junction Box Assembly ............... 48 Axle Assembly ........... 2 Unit Decals ............ 34 Engine Assembly ...........................................................................Front................................................... 30 Engine and Generator to Unit................................................................ 12 Mast Assembly ...................................................................... 3 Unit Decals ......................... 20 Control Box to Unit ........................................Table of Contents Introduction .........................Kubota Left Side ................................................................................... 6 Light Assembly ...............Manual Winch .....................................................................Left Side ................................................................................................ 44 Trailer Assembly .................................................................... 53 v ............................ 14 Mast Assembly ..................................................................... 16 Roof and Doors to Unit ...........................Quick Disconnect Lights Option ..................................................................................................................................................................... 5 Mast................................... 50 Recommended Spare Parts List (1 of 2) ................................. iii Parts Manual Instructions...............................................................................Mitsubishi Right Side ........................................................................................................................... 18 Front............................................................. Junction Box and Lights to Unit .............................................................................................................................................. 22 Control Box Assembly ........................................................ Rear and Side Panels to Unit .............................. 36 Engine Assembly ................................................... 24 Control Panel Assembly ......................................................................................................... 26 Control Panel Assembly ................ 4 Unit Decals ..................Inside Unit ..................................................................................Electric Winch ................................................................................................ MLT4060M ............ 1 Unit Decals ..................Right Side ......... This Page Intentionally Left Blank vi . 0PF 3 ph. shipping address./ PRESS. Record the information from these tags so it is available if the tags are lost or damaged.N. Class FOR ELECTRICAL EQUIPMENT ONLY. POUR MATERIAL ELECTRIQUE SEULEMENT. Refer to the illustration below to locate the unit ID tag and Vehicle Identification Number (VIN) tag on the unit.Parts Manual Instructions Product illustrations are only representations. 1.I. FEDERAL MOTOR VEHICLE SAFETY STANDARDS(FMVSS) AND CANADIAN MOTOR VEHICLE SAFETY REGULATIONS IN EFFECT ON THE DATE OF MANUFACTURE. model number. VIN and tire loading information are found on these tags.V. Parts not shown in the illustration are indicated by a double dash (--) in the item column. Unit ID Tag Located on inside of front panel Manufactured by Generac Mobile Products. part number. Please be prepared to provide the following information when ordering replacement parts: model number. LLC (920) 361-4442 (800) 926-9768 Country of Origin Model Serial Number Manufacturing Code Weight (lbs/kg) RPM/Frequency Rating 1 ph. . XXX000 TRAILER MODEL: V.I. LLC GVWR/PNBV: 000KG (0000LBS) GAWR / PNBE TIRE / PNEU Ins. shipping method. serial number (on unit serial tag). When ordering parts or requesting assistance. you may be asked to provide this information.0PF KW KVA V VIN Tag A Form: SFC626B MANUFACTURED BY/FABRIQUE PAR: Generac Mobile Products./N. Products supplied may vary from the illustrations in this parts manual. DE TIRE AND LOADING INFORMATION RENSEIGNEMENTS SUR LES PNEUS ET LE CHARGEMENT GONF A FROID . such as the unit serial number. CE VEHICULE EST CONFORME A TOUTES LES NORMES QUI LUI SONT APPLICABLES EN VERTU DU REGLEMENT SUR LA SECURITE DES VEHICULES AUTOMOBILES DU CANADA EN VIGUEUR A LA DATE SA FABRICATION.S. 209649 RIM / JANTE DATE: 00/0000 COLD INF. purchase order number (if applicable).: 00000000000000000 TYPE: VOIR LE MANUEL DE L’USAGER POUR PLUS DE RENSEIGNEMENTS 01451 13956 D MLT4060-80K/M Parts Manual 1 . Important information. PRESS. 1.8PF 3 ph.KPA(PSI/LPC) SGL / DUAL The weight of cargo should never exceed 0000KG (0000LBS) Le poids du chargement ne doit jamais depasser 0000KG (0000LBS) EACH AXLE SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION THIS VEHICLE CONFORMS TO ALL APPLICABLE STANDARDS PRESCRIBED UNDER THE U. UNIT DECALS - FRONT, REAR AND TOP PN: 10539 Decal, Instruction 4000 Oval 4 Lang (Manual Winch Units) DANGER DO NOT SET UP UNIT IN HIGH WIND OR DURING ELECTRICAL STORMS! CHECK FOR OVERHEAD OBSTRUCTIONS BEFORE USING! GEFHAR STELLEN SIE NICHT MASSEINHEIT IM STARKEN WIND ODER WÄHREND DER ELEKTRISCHEN STÜRME AUF! ÜBERPRÜFEN SIE AUF OBENLIEGENDE HINDERNISSE, BEVOR SIE VERWENDEN! PELIGRO ¡CNO INSTALE LA UNIDAD EN FUERTE VIENTO O DURANTE TORMENTAS ELÉCTRICAS! ¡CCOMPRUEBE PARA SABER SI HAY OBSTRUCCIONES DE ARRIBA ANTES DE USAR! DANGER N'INSTALLEZ PAS L'UNITÉ EN FORT VENT OU PENDANT LES ORAGES ÉLECTRIQUES ! VÉRIFIEZ LES OBSTRUCTIONS AÉRIENNES AVANT UTILISATION ! WARNING WARNING PN: 10540 Decal, Instruction 4000 Oval 4 Lang (Electric Winch Units) WARNUNG ADVERTENCIA ADVERTISSEMENT STAND CLEAR OF FRONT AND REAR OF MACHINE WHEN MAST IS BEING TILTED UP OR DOWN. WARNUNG AUFENTHALT INVORDERER ODER HINTERER UMGEBUNG DES GERÄTES VERMEIDEN WÄHREND MAST HOCH ODER NIEDER GESCHWENKT WIRD. ADVERTENCIA MANTENGASE ALEJADO DE LA PARTE DELANTERA O TRASERA DE LA MAQUINA MIENTRAS QUE SE ESTA PROCEDIENDO A LEVANTAR EL MASTIL A LA POSICION VERTICAL O VOLCARLO A LA POSICION HORIZONTAL. ADVERTISSEMENT TENEZ-VOUS A DISTANCE DE L’AVANT ET DE L’ARRIERE DE LA MACHINE PENDANT LE BASCULEMENT DU MAT DANS UN SENS OU DANS L’AUTRE. DANGER DO NOT MOVE UNIT WITH TOWER UP! UNIT MUST BE MOVED WITH MAST DOWN AND SECURE IN CRADLE! GEFHAR BEWEGEN SIE EINHEIT MIT DEM TURM NICHT! EINHEIT KANN NUR MIT DEM MAST BEWEGT WERDEN UNTEN UND GESICHERT IN DER WIEGE! PELIGRO ¡NO MUEVA UNIDAD CON TORRE! UNIDAD PUEDE SER SÓLO MOVIDA CON MÁSTIL ¡ABAJO Y ASEGURADO EN CUNA! DANGER NE BOUGEZ PAS D'UNITÉ AVEC LA TOUR EN HAUT! L'UNITÉ PEUT SEULEMENT ÊTRE BOUGÉE AVEC LE MÂT EN BAS ET PROTÉGÉ DANS LE BERCEAU! ALWAYS KEEP TENSION ON CABLES! SLACK MAY CAUSE CABLE DAMAGE AND EXCESSIVE WEAR! IMMER UNTERHALT-SPANNUNG AUF KABELN! LOCKERE MAI URSACHE CABLEDAMAGE UND ÜBERMÄSSIGE ABNUTZUNG! ¡CSIEMPRE TENSIÓN DE LA SUBSISTENCIA EN LOS CABLES! ¡CCAUSA FLOJA CABLEDAMAGE DE MAYO Y DESGASTE EXCESIVO! TOUJOURS TENSION DE SUBSISTANCE SUR DES CÂBLES ! CAUSE LÂCHE CABLEDAMAGE DE MAI ET USAGE EXCESSIF ! WARNING PN: 12140 Decal Set, Common Mast 4 Lang STAND CLEAR OF FRONT AND REAR OF MACHINE WHEN MAST IS BEING TILTED UP OR DOWN. WARNUNG AUFENTHALT INVORDERER ODER HINTERER UMGEBUNG DES GERÄTES VERMEIDEN WÄHREND MAST HOCH ODER NIEDER GESCHWENKT WIRD. ADVERTENCIA MANTENGASE ALEJADO DE LA PARTE DELANTERA O TRASERA DE LA MAQUINA MIENTRAS QUE SE ESTA PROCEDIENDO A LEVANTAR EL MASTIL A LA POSICION VERTICAL O VOLCARLO A LA POSICION HORIZONTAL. Located on bottom side of mast GEFAHR ENTFERNEN SIE NICHT! PELIGRO NO QUITE! DANGER N'ENLEVEZ PAS ! ADVERTISSEMENT DANGER DANGER DO NOT REMOVE! GEFAHR PELIGRO DANGER TENEZ-VOUS A DISTANCE DE L’AVANT ET DE L’ARRIERE DE LA MACHINE PENDANT LE BASCULEMENT DU MAT DANS UN SENS OU DANS L’AUTRE. PN: 13614 Decal, Mast Junction Box Wiring, 4 Light Located on inside cover of mast junction box TOWING INSTRUCTIONS ABSCHLEPPINSTRUKTIONEN INSTRUCCIONES DE REMOLQUE INSTRUCTIONS DE REMORQUAGE 1. READ OPERATOR'S MANUAL. 2. USE HITCH RATER FOR TRAILER'S "GROSS VEHICLE WEIGHT RATING". 3. SECURELY ATTACH TRAILER TO TOW VEHICLE. 4. ATTACH SAFETY CHAINS USING A CROSS PATTERN. 5. ATTACH BREAKDOWN CHAIN TO VEHICLE. 6. CHECK TRAILER LIGHTS. 1. BETRIEBSVORSCHRIFT LESEN. 2. ANHÄNGEVORRICHTUNG VERWENDEN, DIE DER GESAMTBETRIEBSGEWICHTSKLASSE ENTSPRICHT . 3. ANHÄNGER SICHER AM ZUGFAHRZEUG BEFESTIGEN. 4. SICHERHEITSKETTEN KREUZWEISE ANBRINGEN. 5. ABREISSKETTE AM FAHRZEUG ANBRINGEN. 6. ANHÄNGERLEUCHTEN PRÜFEN. 1. LEA EL MANUAL DEL OPERARIO. 2. UTILICE UN ACOPLE CORRECTAMENTE CLASIFICADO PARA LA "CLASE DE PESO BRUTO" DEL VEHICULO DE REMOLQUE 3. ASEGURESE DE ACOPLAR CORRECTAMENTE EL REMOLQUE AL VEHICULO DE REMOLQUE. 4. FIJE EN CRUZ LAS CADENAS DE SEGURIDAD. 5. FIJE EN EL VEHICULO DE REMOLQUE LA CADENA DE DESPRENDIMIENTO. 6. CONTROLE LAS LUCES DEL REMOLQUE. 1. LIRE LA NOTICE D’EMPLOI. 2. UTILISER UN CROCHET D’ATTELAGE CONFORME AU DEBIT NOMINAL DU POIDS BRUT DE VEHICULE DU VEHICULE TRACTEUR. 3. ATTACHER LA REMORQUE FERMEMENT AU VEHICULE TRACTEUR. 4. ATTACHER LES CHAINES DE SURETE EN UTILISANT UNE METHODE CROISEE. 5. ATTACHER LA CHAINE DE REMORQUAGE AU VEHICULE. 6. VERIFIER LES LAMPES DE LA REMORQUE. PN: 50960 Decal, Mast Telescope/Control Electric Winch 01452 Located by toggle switches Note: All safety and operating decals are located on decal sheet 12141, unless otherwise noted. 2 MLT4060-80K/M Parts Manual 13956 D UNIT DECALS - LEFT SIDE DANGER COMPLETELY LOWER TOWER BEFORE TILTING MAST. TILTING AN EXTENDED MAST COULD CAUSE SERIOUS INJURY OR DEATH. GEFAHR VOR DEM EINSCHWENKEN DES MASTES, BELEUCHTUNGSTURM GANZ NIEDERLASSEN. EINSCHWENKUNG DES VERLÄNGERTEN MASTES KANN SCHWERE VERLETZUNG ODER TOD HERVORRUFEN. PELIGRO BAJE EL MASTIL COMPLETAMENTE ANTES DE VOLCARLO A LA POSICION HORIZONTAL. EL VOLCAR UN MASTIL EXTENDIDO PUEDE LLEGAR A CAUSAR GRAVES HERIDAS O MUERTE. DANGER RABAISSEZ COMPLETEMENT LE MAT AVANT DE LE BASCULER. LE GASCULEMENT D’UN MAT DEPLOYE PEUT PROVOQUER DE SERIEUSES BLESSURES ET MEME LA MORT. DANGER PN: 12140 Decal Set, Common Mast 4 Lang CONTACT WITH OVERHEAD ELECTRICAL POWER LINES WILL CAUSE SERIOUS INJURY OR DEATH. DO NOT POSITION LIGHT TOWER UNDER ELECTRICAL POWER LINES. WARNING SECURE MAST IN TRANSPORT LOCK BEFORE LIFTING OR TOWING! GEFAHR WARNUNG KONTAKT MIT OBERIRDISCHEN STROM FREILEITUNGEN KANN ZU SCHWEREN VERLETZUNGEN ODER TOD FÜHREN. NIEMALS BELEUTUNGSTURM UNTER ELEKTRISCHEN LEITUNGEN AUFSTELLEN. DEN MAST VOR DEM ANHEBEN ODER ABSCHLEPPEN IN DER TRANSPORTHALTERUNG SICHERN! PELIGRO ADVERTENCIA EL CONTACTO CON CABLES ELECTRICOS DE TENDIDO AEREO CONDUCIRA A GRAVES HERIDAS O MUERTE. NUNCA UBIQUE LA TORRE DE LUZ DEBAJO DE CABLES ELECTRICOS DE TENDIDO AEREO. FIJE EL MASTIL EN LA TRABA DE TRANSPORTE ANTES DE REMOLCAR O LEVANTAR EL MISMO. DANGER ADVERTISSEMENT TOUT CONTACT AVEC DES CABLES ELECTRIQUES AERIENS PEUT PROVOQUER DE SERIEUSES BLESSURES ET MEME LA MORT. NE POSITIONNEZ PAS LE MAT DECLAIRAGE SOUS DES CABLES ELECTRIQUES AERIENS. VERROUILLEZ SOLIDEMENT LE MAT POUR LE TRANSPORT AVANT DE LE HISSER OU DE LE REMORQUER. Located on manual holder Located on inside of door DANGER ENGINE OPERATION / MOTORBETRIEB / FUNCIONAMIENTO DEL MOTOR / FONCTIONNEMENT DU MOTEUR: 1 BEFORE STARTING THE ENGINE / VOR DEM STARTEN DES MOTORS / ANTES DE ENCENDER EL MOTOR / AVANT DE FAIRE DÉMARRER LE MOTEUR: 1. CHECK FUEL LEVEL. TREIBSTOFFSTAND PRÜFEN. REVISE EL NIVEL DE COMBUSTIBLE. VÉRIFIER LE NIVEAU D’ESSENCE. GEFAHR PELIGRO DANGER 3. CHECK COOLANT LEVEL. KÜHLMITTELSTAND PRÜFEN. REVISE EL NIVEL DEL REFRIGERANTE. VÉRIFIER LE NIVEAU DE LIQUIDE DE REFROIDISSEMENT. 2. CHECK ENGINE OIL LEVEL. 4. MAKE SURE MAIN CIRCUIT BREAKER IS OFF. MOTORÖLSTAND PRÜFEN. VERGEWISSERN SIE SICH, DASS DER HAUPTTRENNSCHALTER REVISE EL NIVEL DE ACEITE DEL MOTOR. AUSGESCHALTET IST. VÉRIFIER LE NIVEAU D’HUILE DU MOTEUR. ASEGÚRESE DE QUE EL CORTACIRCUITOS PRINCIPAL ESTÉ APAGADO. S’ASSURER QUE LE DISJONCTEUR DU CIRCUIT PRINCIPAL EST DÉSACTIVÉ. Located on control box 2 3 ALL CIRCUIT BREAKERS OFF! / ALLE TRENNSCHALTER SIND AUSGESCHALTET! / ¡TODOS LOS CORTACIRCUITOS ESTÁN APAGADOS! / TOUS LES DISJONCTEURS DU CIRCUIT SONT DÉSACTIVÉS! OFF GLOW PLUG I O I O I O RELEASE KEY OFF OFF RUN GLOW PLUG GLOW PLUG RUN START GLÜHKERZEN AKTIVIEREN ACTIVE LAS BUJÍAS DE CALEFACCIÓN ACTIVER LES BOUGIES DE PRÉCHAUFFAGE 4 I O CRANK ENGINE TO START ACTIVATE GLOW PLUGS DANGER I O START ENGINE / MOTOR STARTEN / ENCIENDA EL MOTOR / FAIRE DÉMARRER LE MOTEUR RUN START START MOTOR ZUM STARTEN AUF VOLLEN TOUREN LAUFEN LASSEN PONGA EN FUNCIONAMIENTO EL MOTOR PARA QUE ARRANQUE ACTIONNER LE MOTEUR POUR LE FAIRE DÉMARRER TURN CIRCUIT BREAKERS ON / TRENNSCHALTER EINSCHALTEN / ENCIENDA LOS CORTACIRCUITOS / ACTIVER LES DISJONCTEURS DU CIRCUIT SCHLÜSSEL FREIGEBEN SUELTE LA LLAVE RELÂCHER LA CLÉ I O I I I I O O O O I O I O SHUT DOWN / AUSSCHALTEN / APAGUE / ÉTEINDRE 5 A NON-SECURED, FALLING MAST WILL CAUSE SERIOUS INJURY OR DEATH IF A PERSON IS HIT. TO SECURE MAST, INSERT THE LOCK BAR INTO MAST MOUNTED BRACKET THEN INSERT PIN. GEFAHR 6 EIN UNGESICHERTER HERABFALLENDER MAST KANN SCHWERE, ODER VERLETZUNGEN VERURSACHEN, WENN ER AUF EINE PERSON FÄLLT. ZUM SICHERN DES MASTES DIE VERRIEGELUNGSSTANGE IN DIE MASTMONTIERTE HALTERUNG STECKEN UND DANN DEN SICHERUNGSSTIFT EINSTECKEN. PELIGRO ALL CIRCUIT BREAKERS OFF! / ALLE TRENNSCHALTER SIND AUSGESCHALTET! / ¡TODOS LOS CORTACIRCUITOS ESTÁN APAGADOS! / TOUS LES DISJONCTEURS DU CIRCUIT SONT DÉSACTIVÉS! STOP ENGINE / MOTOR STOPPEN / DETENGA EL MOTOR / ÉTEINDRE LE MOTEUR OFF TURN MAIN BREAKER OFF OFF I O I O I O RUN START WARNING UN MASTIL INCORRECTAMENTE FIJADO PODRIA CAUSAR LESIONES SEVERAS O MUERTE AL CAER SOBRE UNA PERSONA. PARA FIJAR EL MASTIL, INTRODUZCA PRIMERO EL PERNO DE BLOQUEO DENTRO DE LA PIEZA DE FIJACION DEL MASTIL Y LUEGO COLOQUE EL PASADOR DE SEGURIDAD. I O OFF GLOW PLUG WARNING TURN MAIN BREAKER OFF Read and understand the supplied operator’s manual before operating this machine. Failure to do so increases the risk of injury to yourself or others. DANGER WARNUNG Make sure main circuit breaker is off before starting engine. LA CHUTE D’UN MAT MAL FIXE SUR UNE PERSONNE PEUT ENTRAINER DES BLESSURES GRAVES OU LA MORT. POUR FIXER SOLIDEMENT LE MAT, INSEREZ LA BARRE DE VERROUILLAGE DANS LE SUPPORT DU MAT, PUIS INSEREZ LA BROCHE. WARNUNG Vergewissern Sie sich, dass der Hauptunterbrecher ausgeschaltet ist, bevor der Motor gestartet wird. ADVERTENCIA Asegúrese de que el cortacircuitos esté en la posición “off” (apagado) antes de encender el motor. Vor dem Betrieb dieser Maschine muss das Bedienerhandbuch gelesen und verstanden worden sein. Ein Unterlassen erhöht das eigene Verletzungsrisiko und das anderer. ADVERTENCIA Lea y asegúrese de comprender el manual del operador proporcionado antes de operar esta máquina. De lo contrario, aumenta el riesgo de lesiones a usted y a otras personas. AVERTISSEMENT AVERTISSEMENT S’assurer que le disjoncteur du circuit principal est désactivé avant de faire démarrer le moteur. Lire et comprendre le manuel de l’utilisateur fourni avec l’appareil avant de l’utiliser. L’omission de le faire augmente le risque de blessure pour vous et pour les autres. 01453 Note: All safety and operating decals are located on decal sheet 12141, unless otherwise noted. 13956 D MLT4060-80K/M Parts Manual 3 UNIT DECALS - RIGHT SIDE PN: 12140 Decal Set, Common Mast 4 Lang WARNING SECURE MAST IN TRANSPORT LOCK BEFORE LIFTING OR TOWING! WARNUNG DEN MAST VOR DEM ANHEBEN ODER ABSCHLEPPEN IN DER TRANSPORTHALTERUNG SICHERN! ADVERTENCIA FIJE EL MASTIL EN LA TRABA DE TRANSPORTE ANTES DE REMOLCAR O LEVANTAR EL MISMO. ADVERTISSEMENT VERROUILLEZ SOLIDEMENT LE MAT POUR LE TRANSPORT AVANT DE LE HISSER OU DE LE REMORQUER. WARNING WARNUNG ADVERTENCIA ADVERTISSEMENT ULTRA LOW SULFUR FUEL ONLY S≤15 mg/kg PN: 27433 Decal, Ultra Low Sulfur Fuel Only DANGER GEFAHR PELIGRO Located inside front panel DANGER DIESEL Located inside front panel 01454 Note: All safety and operating decals are located on decal sheet 12141, unless otherwise noted. 4 MLT4060-80K/M Parts Manual 13956 D 13956 D MLT4060-80K/M Parts Manual 5 . Ground WARNING WARNUNG ADVERTENCIA ADVERTISSEMENT 00744 Note: All safety and operating decals are located on decal sheet 12141.INSIDE UNIT WARNING WARNUNG ADVERTENCIA ADVERTISSEMENT WARNING WARNUNG ADVERTENCIA ADVERTISSEMENT PN: 12142 Decal.UNIT DECALS . Ground WARNING WARNING WARNUNG ADVERTENCIA ADVERTISSEMENT WARNUNG ADVERTENCIA ADVERTISSEMENT DANGER WARNING GEFAHR PELIGRO DANGER WARNUNG ADVERTENCIA ADVERTISSEMENT PN: 12142 Decal. unless otherwise noted. MAST. JUNCTION BOX AND LIGHTS TO UNIT 4 5 3 2 5 6 1 8 7 9 10 5 16 11 12 13 17 14 15 32 18 19 15 31 20 29 13 21 25 30 23 24 28 27 23 22 25 26 25 26 6 MLT4060-80K/M Parts Manual 01455 13956 D . . .50 std hex. .500-13 hex. G5 Assembly.. compression .500-13 x 1. .125 x 1..1. SS Nut.375 flat .50 std hex.750 flat 1.500-13 nylock.875/. G5 Assembly. SS Sheave . .875/.25 Assembly.060 Pin.. SS Nut. SS Spring. kickback .250 x 1. . cotterless . . SS Pin. . light Screw.500 flat . clevis . split .500 split lock. SS Washer.054 Pin.080 SS Bracket.kick-back spring MLT4060-80K/M Parts Manual Notes 7 .0 Spring.500-13 x 5.50 lb Spacer plate .75 Washer. . door adjustment Washer..375-16 x 3.50 std hex. G5 Screw. SS Chain.50 std hex.0. . 60584 13536 13020 60753 60698 60358 Page 8 15292 60690 60703 14229 60702 60699 14459B 60744 15165 11215 14663Z 60706 60707 14403 14275 15380 35655 60309 62221 60683 14261 60659 60732 14845B 11554Z Qty 1 1 1 2 6 2 4 1 2 2 2 2 4 1 2 1 1 1 1 .750-10 nylock.500 flat 1. mast junction box Screw.070/. latch Ring.500-13 x 5.2 in Screw.040.312 x 1.375 split lock. .375-16 x 1.500 dia x 1. G5 Washer.MAST. roll .. SS Washer.60 OD x 2. G2 Washer. SS Nut. cotter .58 ft 1 1 2 1 10 8 6 1 2 2 1 1 Description Nut.25/.0 std hex.75 x . .063.250 Pin. latch bar Bar. G5 Screw. .0 std hex. JUNCTION BOX AND LIGHTS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 13956 D Part No.750-10 x 6. . sash. mast Assembly. SS Screw. .375-16 nylock. . LIGHT ASSEMBLY 35 1 34 2 3 4 2 33 5 32 31 A 6 7 8 30 9 10 27 29 12 28 27 26 15 2 2 11 5 14 13 17 16 18 19 20 15 10 25 24 B 9 8 21 D 7 23 C 22 01154 8 MLT4060-80K/M Parts Manual 13956 D . 750 flat 2. weathertight . M5 x 12 flg hex.500NPT watertight. M5 x 12 phillips green Socket. housing Nut. glass Assembly.. G5 Washer. socket end plate Bulb. 10-32 x . nipple . ground Nut.020/.500 Connector.quick disconnect. M4 x 10 pan phil Bracket.. slotted Screw.464 ID Handle. SS Clip. housing/trunnion w/cord Bracket. power .500-13 nylock.750 external star Trunnion Bracket. lens Lens. cord clip MLT4060-80K/M Parts Manual Notes Items 1 .LIGHT ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 -- Part No. nylock Assembly.090 Stud.500 Strain relief. 13399 13371 13372 13370 13395 13438 62221 60247 13392 13390 13374 13393 13381 13396 13378 13366 15861 13386 13387 15864 13403 61174 13368 13380 13375 13377 13388 13394 13376 11391 13373 13369 13367 13398 13397 13311 OPTIONAL FEATURES Quick Disconnect Light: A 13383 B 60398 C 19041 D 60061 -13601 13956 D Qty 1 4 2 1 2 1 2 2 2 4 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 1 10 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Description Screw. light . 1000W MH short length Gasket. #4 nylon Assembly. tether Nut. M4 nylock Cord. spring holder Nut. M4 x 18 pan phil Washer. non socket end plate Screw.wing nut Washer. silicone Assembly.hard wired Cord. .500NPT lock Fitting.270/. . . . T . power quick disconnect Screw. housing/trunnion w/out cord Screw.35 Replaces item 6 9 . 10-32 nylock Assembly. . #4 Washer. bulb support Support. light .500 pan phil. special.500 nylon Support. aluminum ring Screw. . . bulb w/out threaded insert Screw. trunnion mounting Washer.hard wired Nut. pan phillips Gasket. HARD WIRED LIGHTS 1 2 3 4 5 6 10 8 8 9 7 14 8 9 8 10 13 11 12 12 01155 10 MLT4060-80K/M Parts Manual 13956 D .MAST JUNCTION BOX ASSEMBLY . 10-32 nylock.500 Nut.500FNPT. G2 Gasket.hard wired MLT4060-80K/M Parts Manual Notes Items 1 .464 Strain relief ..270/.545/.750MNPT x ..750 pan phil. SS Bracket. 10-32 x . nylon Screw.HARD WIRED LIGHTS Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 -- 13956 D Part No. 3 position Connector.. mast junction box . junction box Connector. 6-32 x . .709 Fitting. 2 gang plastic Screw. box.14 11 .MAST JUNCTION BOX ASSEMBLY . .500NPT watertight. junction box Box.750 pan phil. G2 Clamp. 5 position Strain relief . junction Assembly. 2 position Connector.750NPT watertight. 12109 60424 13749 66100 66101 66102 15864 14656 60755 60062 16143 60415 12095B 12094 11789 Qty 1 4 1 4 2 1 4 1 2 5 1 5 1 1 1 Description Cover.. strt . tubing . MAST JUNCTION BOX ASSEMBLY .QUICK DISCONNECT LIGHTS OPTION 1 16 2 3 4 10 5 9 6 11 7 12 8 9 11 10 12 13 15 14 14 01540 12 MLT4060-80K/M Parts Manual 13956 D . female Assembly. SS Bracket. junction Fitting. 10-32 nylock. 60424 66100 66101 66102 13749 12094 12713 14656 15403 12410 60755 60062 16143 60415 12095B 12109 11957 Qty 4 4 2 1 1 1 1 1 4 4 2 5 1 5 1 1 1 Description Screw. junction box Box. nylon Screw. junction box . 10-32 x . G2.750 pan phil.750NPT. 5 position Gasket.. mast junction box . quick disconnect receptacle cap w/chain Fitting.black Cover. .QUICK DISCONNECT LIGHTS OPTION Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 -- 13956 D Part No.. box. G2 Clamp.750 pan phil.quick disconnect MLT4060-80K/M Parts Manual Notes Items 1 .500MNPT x . self thread Connector. 6-32 x .500FNPT. quick disconnect . 2 position Connector. tubing . 3 position Connector. strt . strt . 2 gang plastic Assembly.500FNPT. watertight Connector..500 Nut.16 13 . steel Strain relief.750MNPT x .MAST JUNCTION BOX ASSEMBLY . MANUAL WINCH B A 25 C 6 D 24 7 E 23 26 8 4 25 1 24 5 9 2 23 10 5 4 29 26 27 28 3 2 12 1 30 2 7 27 19 22 6 11 21 19 9 6 20 9 17 18 9 12 13 14 15 16 01369 14 MLT4060-80K/M Parts Manual 13956 D .MAST ASSEMBLY . 0 Screw.33 ft MLT4060-80K/M Parts Manual Notes Nut included Attaches to item 3 Attaches to item 17 Attaches to item 22 Replaces coil cord 15 . . 10-32 nylock 18-8. steel w/teardrop Cord. x 27 ft. mast crossbar Weldment..130 Weldment. 10-32 nylock Weldment.. G2 Reflector ..3.MAST ASSEMBLY .375 pan phil. tubing . .750 flat 2.0 Nut. mast .188 dia x .500 cord Shim .1500 lb Winch handle .LH Nut.020/. wire rope ... 10-32 x . .2.063 Strain relief.375 split lock. x 11 ft.188 4 1 1 4 4 Screw..500 Weldment.9. steel w/ball swedge Cable . oval light storage . cable . . single saddle Thimble. clevis . T-bolt Washer. .375-16 x 1. coil Clip.312 split lock Sheave .500 dia x 1. . tubing .188 in. SS 1 Cord.red Nut. G5 Winch.750 pan phil. .5 std hex. G5 Weldment.375-16 x 5.0 carr sqr.126 to . SS Cable . oval light storage .750 std hex.625 heavy duty Rivet. 60268 16143 11933B 60168 60271 14262 32569 13790 63325 14871 13789 60062 15829 60061 13527B 16257B 11934B 60584 60658 11649Z 60247 11902B 60698 60206 60140 16600 15623 15627 60195 60415 15006 14151 14798 11954 15002 15003 OPTIONAL FEATURES Mast Light Storage: A 60780 B 13869B C 13870B D 60679 E 60703 Drape Cord: -14128 13956 D Qty 2 3 1 2 2 3 15 1 5 1 1 3 1 2 1 1 1 1 6 1 1 1 6 6 6 2 2 1 1 1 1 1 1 1 2 1 Description Rivet.500 grip large flange S Nut. G5 Weldment. . drape .RH Weldment.312 x 18 x . mast . mast tube Washer. .500NPT.0 in Clamp.188 dia x .250 grip Clamp. SS Washer.3x3 tube Screw.750-10 nylock. G5 Screw.375 flat .4.MANUAL WINCH Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 ------- Part No.188 in. .0 Weldment.375-16 hex. .875/.4x4 tube Pin.375 split lock Nut.3 in Screw.375 to . manual . . . . .040 18-8. SS Shim . 8-16 x ..375-16 hex. G5 Washer. mast . SS Washer.188.188 in. steel w/ball swedge Cable . x 16 ft. ELECTRIC WINCH 40 38 39 4 17 21 17 5 41 36 37 6 34 10 9 21 33 35 36 34 11 7 1 34 2 8 3 12 14 32 31 8 8 7 4 13 7 15 2 3 5 21 3 17 6 16 18 28 9 10 30 15 26 26 25 19 9 29 12 27 20 21 2 22 2 23 12 17 24 01404 16 MLT4060-80K/M Parts Manual 13956 D .MAST ASSEMBLY . x 11 ft steel w/ball swedge Thimble..500 Assy. 12V Cover.188 in.770 lb hoist Screw.064 Screw. x 16 ft steel w/teardrop Cable . .ELECTRIC WINCH Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 ---------- 13956 D Part No.50NPT. .0 Shim . red Weldment. T-bolt Screw.3.188 dia x .4. mast .375-16 nylock.188.188 Clip.250-20 nylock. wire rope ..020/.0 Screw.0 Nut. battery cable Cable .188 in.MAST ASSEMBLY . rolled screw Shim . mast . 10-32 x . winch mounting Winch.. winch contactor Nut.. . .4x4 tube Pin.50 cord Weldment.750 flat 2.375-16 x 3. mount Rivet.250 grip.2. mast crossbar Weldment.0 carr sqr.250-20 x . x 27 ft steel w/ball swedge Cable .750 std hex.SPDT. . G5 Wire group. 12V 30/40A NO w/diode Switch..3 in Screw.750 pan phil. . spring weatherproof Contactor. G5 Weldment.3x3 tube Weldment. electric winch Wire group. SS. G5 Washer. G5 Washer. . electric winch cables Boot. SS Clamp. . .500 dia x 1.312 Weldment. proximity Screw.250 flat . single saddle Cord.126 to .735/.0 carr sqr.188 dia x . cable . G5 Nut.75 Strain relief .060 Relay. coil MLT4060-80K/M Parts Manual Notes Hardware included Attaches to item 18 Attaches to item 29 Attaches to item 20 17 .375 to . tubing . clevis .993/..375-16 x 1..50 std hex. G5 Clamp. . electric winch Nut. .. toggle .312-18 x 7. tubing . 11967B 60268 16143 10649 60358 60386 60168 60271 14262 32569 13790 35655 14871 13796B 65511 60991 60061 12085B 13789 12084B 60062 15829 13527B 16257B 60584 60375 11649Z 60658 12876B 60247 15627 60195 12872B 12874 60281 60243 65049 65707 11293 12875B 60144 35845 66819 12922 15006 14798 14151 15003 15002 11954 Qty 1 5 3 2 4 4 5 5 3 15 1 5 1 1 2 2 5 1 1 1 9 1 1 1 1 3 1 2 1 1 1 1 2 2 8 16 2 2 2 2 8 1 1 4 1 1 1 1 1 1 Description Tube. . mast .188 in.312 split lock Sheave .. tubing .. proximity sensor bracket Sensor. G2 Reflector. electric .500 grip large flange Bracket.625 Rivet. G5 Washer.130 Clamp. mast tube Washer.375 flat . 8-16 x . 10-32 nylock Weldment.375 pan phil. . .750-10 nylock. ROOF AND DOORS TO UNIT A F 5 B 7 1 C 4 12 15 6 2 8 3 16 8 9 B 11 12 10 D 12 11 13 13 14 12 15 12 E 01485 18 MLT4060-80K/M Parts Manual 13956 D . SS Washer.0 std hex.500 flat 1. SS Weldment. . rubber Assembly.. .375 flat . ZTR M6H 1 Level. . .750 pan phil Washer.ROOF AND DOORS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part No. x .250 grip.188 pin.500-13 hex. ZTR M6H Nut.070/. top 2 4 1 2 1 1 Screw. SS Panel. . paddle .5 in. door Latch.435/. flat .875/.040. 10-32 nylock Clip.060 Telemetry.500 split lock. SS Washer. .7 lb spring Door latch SS . long Rivet. SS Washer. SS Nut.375 split lock.50 std hex. cradle Pad. G2 Hinge.375-16 x 1. . SS Washer.188 dia.T-style Panel.500-13 x 1. cradle pin Screw. rod hold Harness. 48. door . 60690 60703 60698 12344ZN 11935 16099 60683 60699 60702 14229 16598 60268 16591W 15123 12605 16538W OPTIONAL FEATURES Telemetry: A 61180 B 60067 C 37731 D 60061 E 61055 -37785 Level Indicator: F 14433 13956 D Qty 4 4 4 1 1 1 2 4 2 2 2 48 2 2 2 1 Description Screw.080.126 to . eye MLT4060-80K/M Parts Manual Notes 19 . . 10-32 x . FRONT. REAR AND SIDE PANELS TO UNIT 4 3 1 2 A 6 41 12 11 5 8 10 9 13 14 18 16 15 38 33 16 7 19 27 39 40 14 20 15 14 2 23 21 24 16 32 6 22 17 16 25 15 15 37 26 15 2 15 26 26 36 35 29 30 27 28 31 32 15 16 34 33 B E F G C D 20 01465 MLT4060-80K/M Parts Manual 13956 D . 250 to .13 in. G5 Clamp.375-16 hex. . rubber Rivet. G5 Washer. .375 grip Nut.50/. wire . G2 Washer.040.875/. 8-32 U-clip Rubber bumper Rivet.435/.188 dia x . 12 GA Assembly. alum Light. overflow jug Bracket. .FRONT. G5 Screw. .25 Romex. SS Washer.188 dia x .0 std hex.250 grip.375 split lock. . rear light.875/.. 10-24 x .375-16 x . REAR AND SIDE PANELS TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 Part No.375-16 x 1. radiator guard Nut. .250-12 x 1.312 flat . . SS Nut.38 Nut. 3-wire w/plug Grommet.126 to . SS Panel.750 std hex.625/. 35500W 60657 10223 60423 60457 60067 10219 10221 60268 11222 60089 60540 15628 60140 60698 60703 60649 19714 20287 60061 60696 60144 60414 19726 22419B 60689 66372 60694 60730 15215 60267 66373 16560 60690 35501W 33746W 66425 60295 60729 12025W 11121 OPTIONAL FEATURES Silent Pack: A 12189W B 15425 C 34744W D 34783W E 60507 F 60701 G 60340 13956 D Qty 1 26 1 2 2 2 2 2 2 1 2 2 2 10 38 36 1 1 1 1 1 1 1 1 1 10 2 8 8 6 6 2 2 22 1 1 1 8 8 1 1 Description Panel.375-16 cage. SS Clamp. SS Light. tire Screw.040.125 dia. overflow jug Screw.750 pan phil.375-16 x 4. front Strain relief.050. rear Nut. .312-18 x 1.312-18 cage Panel. w/nut Screw.375 flat .0 std hex.0 std hex. SS MLT4060-80K/M Parts Manual Notes 21 .750 pan phil. SS Assembly. SS Nut. SS Bracket.red Screw. SS Washer. manual holder Washer. 8-32 x .250 flat . .312 split lock. clearance marker . . 10-24 nylock. clearance marker . .25/. tubing . . . . . front Screw.250-20 nylock. . . overflow Nut. G5.. plastic .750 heavy duty Cap. left side Panel. #10 flat .50 std hex. x . SS Washer.265 fender 1.090 Panel.060. right side Manual holder tube 1 16 1 2 16 16 16 Duct.271 grip. .191 to . rear tail/turn light. 1. . SS Clamp.375 fender 1. 10-32 nylock Washer. SS Washer. front Duct.060 Screw. license plate holder Rivet. overflow jug Jug.amber Fender. CONTROL BOX TO UNIT 3 2 1 4 3 2 5 6 7 8 9 A B C E F 2 H G 10 J D 2 N 10 K L M G R Q P 01466 22 MLT4060-80K/M Parts Manual 13956 D . disconnect Cable..375 lug Cable.070 Screw. #10 flat . . SS Nut.CONTROL BOX TO UNIT Item 1 2 3 4 5 6 7 8 9 10 Part No.312-18 nylock.24 in.435/.060. . battery . 60649 60340 60303 Page 24 11543B 60090 60089 12924B 14146 62043 OPTIONAL FEATURES Battery Charger: A 60694 B 60067 C 65326 D 60270 -21259 Battery Disconnect: E 60028 F 60271 G 60119 H 60277 J 65499 K 13654B L 60067 M 60061 N 65498 P 10699 Q 10698 R 60303 13956 D Qty 1 12 6 1 2 2 2 1 2 6 Description Clamp.500 pan phil.250-20 x 10.750 heavy duty Washer.312-18 x 2. SS 2 2 1 2 1 Screw.312 split lock Washer. 10-32 x .250 flat Angle. battery disconnect Washer. G2 MLT4060-80K/M Parts Manual Notes Included w/item 9 Included w/item 9 23 .060. . wing . G2 Assembly.375 lug Nut.0 std hex.312-18 x 1.312-18 nylock. .312 flat .. 8-32 nylock Decal. #10 flat . tubing . battery . . . control box Nut.040. . battery hold down Bolt.750 pan phil. 4GA black..0 Screw. battery . 4GA black.435/.875/. 10-32 nylock Switch. 8-32 x . SS Washer. .21 in. G2 Control box Spacer. G5 Washer.250 x 20 Washer.25 std hex. . SS Charger. . J .2A Nut. SS Nut. switch lockout lever Bracket.312 flat .875/. battery charger 2 2 2 2 1 1 2 2 1 1 1 2 Screw. CONTROL BOX ASSEMBLY 2 3 1 20 19 18 7 17 15 14 16 8 5 14 4 6 13 A 7 12 9 8 7 7 9 B C 10 11 01467 24 MLT4060-80K/M Parts Manual 13956 D . 10-32 x .500 pan phil. 8kW Notes MLT4060K/M only MLT4080K/M only MLT4060K only MLT4060M only MLT4060K/M only MLT4080K only MLT4080M only MLT4060K only MLT4060M only MLT4080K only MLT4080M only Fitting. #10 split lock Nut.8kW control box Assembly. G2 Wire group .. terminal . G2 Strain relief . bushing .375 Light. control box . 600V Nut.CONTROL BOX ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 ---------- Part No. 6kW Assembly.6kW control box Wire group . self-drilling MLT4060-80K/M Parts Manual 25 .15 second Assembly.750 Romex w/nut Washer. 10A SPDT 12VDC.10 position. control box . M12-1. terminal . 10-32 hex. control box .6kW control box Wire group . G2 Screw.. stud mount Screw. control panel Assembly. time delay .6kW control box Wire group .Kubota.750 pan phil. SS Capacitor. 30A.Mitsubishi.500 std hex. interior with switch Screw. 6kW Assembly.500 x .75 sflg. 10-32 x 1. control panel Screw. 10-16 x . G5 Box.12 position.25 pan phil. 10-32 nylock Relay.8kW control box Wire group . control Screw. G2 Block. 13690B 60148 60398 65959 60397 60396 14219 60252 60061 14201 Page 26 Page 28 60526 15125 14231 14203 14139 61045 63105 13666B 60062 35270 35271 68441 35310 10438 17790 17789 35089 32984 OPTIONAL FEATURES Interior Light: A 19163 B 11947 C 60364 13956 D Qty 2 2 4 2 1 1 5 3 2 1 1 1 6 1 3 1 1 4 6 1 3 1 1 1 1 1 1 1 1 1 1 1 4 Description Bracket.Kubota. 8-32 x .0 pan phil. 30A.Mitsubishi. G8. G2 Jumper Nut. 600V Block. capacitor Nut. 10-32 x 1.500 pan phil. dual 24μF sealed. 10-32 sflg Nut. G2. control box . 8-32 U-clip. 8kW Assembly. 10-32 x .8 Screw. CONTROL PANEL ASSEMBLY . MLT4060M 1 2 3 23 24 22 21 6 4 5 7 19 8 18 9 20 10 17 19 18 12 11 14 16 14 15 26 13 MLT4060-80K/M Parts Manual 01164 13956 D .MLT4060K. 8-32 hex.2 ID x .0 pan phil. 1-pole Receptacle. G5 Kit. hour meter Washer. push button Nut. 6kW Light. continuous . 10-32 x . stud terminal w/aux Breaker. 240V/30A twist-lock Receptacle. G2 Washer. control panel . 120V. 2-pole. #10 split lock Screw.11 in Screw. 120V.Kubota.Mitsubishi Wire group . G2 Screw. plastic Breaker.250 pan phil. LED lights w/connector Nut.MLT4060K.30A twist-lock Wire group . 240V. control . control panel .Mitsubishi. 6-32 x . 1-pole. #6 split lock Screw. 15A. control . 10A.750 pan phil.375 OD x . 120V/20A GFI Nut. 10-32 hex. 6kW Panel.20A GFCI Wire group .light switches Wire group .Kubota Assembly.CONTROL PANEL ASSEMBLY .500 pan phil. 250V. push button Assembly. . 12VDC Breaker. G2 Panel. 1-pole.24 27 . SS Hinge. key Glow plug indicator Breaker. ground bar Switch. 66423 60061 66257 14249 14137 14130 60318 14204 15195 16694 65850 14231 15085 60252 60277 60406 13677 60405 60058 60062 10441 10444 65388 65963 65849 10440 10443 35267 35268 35269 35266 Qty 1 3 3 4 1 1 2 1 1 1 1 2 1 4 2 2 1 16 16 3 1 1 1 1 1 1 1 1 1 1 1 Description PCB. 10-32 nylock Spacer. 10-32 x .LED light board MLT4060-80K/M Parts Manual Notes MLT4060M only MLT4060K only MLT4060M only Items 1 . 8-32 x 1. 10A. indicator red.25 long. G2 Gauge.24 Items 1 . MLT4060M Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 ------- 13956 D Part No. 30A.9 & 11 . CONTROL PANEL ASSEMBLY . MLT4080M 25 24 1 2 23 3 22 21 4 5 7 19 8 18 6 9 20 10 19 17 19 18 18 12 11 14 16 14 15 28 13 MLT4060-80K/M Parts Manual 01468 13956 D .MLT4080K. 240V/30A twist-lock Breaker. 66423 60061 66257 14249 14137 65963 60318 14204 15195 16694 65850 14231 15085 60252 60277 60406 13677 60405 60058 60062 13675 10437 65388 65864 65849 14130 13884 10436 10458 35309 35267 35269 35266 68271 Qty 1 3 3 4 1 1 2 1 1 1 1 2 1 4 2 2 1 22 22 3 1 1 1 1 1 2 1 1 1 1 1 1 1 1 Description PCB.750 pan phil. SS Hinge.0 pan phil. G2 Screw.light switches Wire group . 240V.20A GFCI.11 in Screw. 10-32 nylock Spacer. 2-pole. red Wire group . 10-32 hex. stud terminal w/aux Nut. continuous . G2 Gauge. 2-pole.LED light board Wire group . control panel . 120V.MLT4080K. 250V. 8kW Light. 12VDC Breaker.Mitsubishi Wire group .375 OD x .2 ID x . screw terminal w/aux Breaker. 40A.Kubota. 30A. 10-32 x . 1-pole. black Wire group . 10-32 x .500 pan phil.250 pan phil. push button Receptacle. push button Nut. indicator red.control panel wiring 8kW Wire group .20A GFCI. MLT4080M Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 --------- 13956 D Part No. G2 Washer. 10A. control panel . G2 Panel. LED lights w/connector Nut.Mitsubishi.30A L6-30R MLT4060-80K/M Parts Manual Notes MLT4080M only MLT4080K only MLT4080M only MLT4080K only MLT4080M only 29 . plastic Breaker. G5 Kit. key Glow plug indicator Breaker. 6-32 x . #6 split lock Screw. 1-pole.25 long. 8-32 hex. 10A. .Kubota Assembly.CONTROL PANEL ASSEMBLY . 120V. 8kW Panel. control . 8-32 x 1. ground bar Switch. 15A. 250V. hour meter Washer. #10 split lock Screw. 1-pole Receptacle. control . 120V/20A GFI Assembly. COOLING SYSTEM ASSEMBLY 1 5 8 7 2 6 17 2 3 5 11 12 4 14 15 10 16 6 7 8 13 9 B A 01166 30 MLT4060-80K/M Parts Manual 13956 D . G2.75-1.75) Clamp. 10-16 x .SAE 020 (. engine .875/.875/. w/fan guard . hose .SAE 020 (.lower Clamp.lower Hose.040.lower radiator hose MLT4060-80K/M Parts Manual 31 .500 std hex.75) Heater.SAE 020 (.375 flat . .75-1. hose .SAE 020 (.75-1. radiator . .75-1.0 std hex. SS Washer. SS Nut.312 flat .75) Clamp.COOLING SYSTEM ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Part No. G5 Bracket. radiator .8 Guard.75-1.375 split lock. radiator .SAE 020 (.75) Hose.375-16 x 1. . hose . radiator . SS Washer.070 Washer. tubing . tubing . hose .upper Clamp..25 hex.75) Radiator. fan Screw.625 heavy duty Washer. radiator Clamp. M8-1. self-drilling Hose. .50 light duty Clamp. hose . .welded Notes MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80K only MLT4060/80M only Clamp.375-16 hex. .upper Hose.1.312 split lock Nut. G8. 60690 60698 60703 60140 11683B 15627 60119 60271 60032 11413B 60364 16687 32383 15422 15422 12350 16688 60716 15422 15422 13924 OPTIONAL FEATURES Engine Heater: A 15422 B 65649 13956 D Qty 6 12 6 6 2 2 4 4 4 1 9 1 1 3 2 1 1 1 3 2 1 2 1 Description Screw. ENGINE AND GENERATOR TO UNIT 8 7 1 A To control box B 2 3 C 4 5 1 E G D F 5 1 7 6 5 32 F H MLT4060-80K/M Parts Manual 01470 13956 D . SS Screw.375 split lock Clamp. .. 300 psi Fitting. . plug . .375-16 x 1. wire .0 ID Hose.56-1.375 flat .50 light duty Nut. G5 MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80K only MLT4060/80K only MLT4060/80K only MLT4060/80K only 1 3 ft 1 1 2 1 1 Fitting.1.06) Fitting.375 internal star Assembly. .750NPT square drive Valve.06) Clamp.750NPT street elbow Fitting.4000 engine/chassis ground Washer.ENGINE AND GENERATOR TO UNIT Item 1 2 3 4 5 6 7 8 Part No.5 with nipple Valve. .375 ID. fuel .25-20 nylock.375-16 hex. tubing . crimp style Hose. drain 22mm . G5 Washer. 50 psi Screw. drain 22mm . drain 18mm .5 with nipple Clamp. . hose .0 std hex.625 barb MLT4060-80K/M Parts Manual 33 .5 with nipple Clamp.1. . SS Washer. std hex. bushing .25 x 16..56-1. .625 in. G5 Notes 1 1 1 1 1 1.375 flat .8 Nut.2.312.1.625 horizon 200 psi (22 in) Hose.. hose . .67 ft 1 2 1 1 1 Valve..375 split lock Washer.split lock Screw. strt .375-16 x 1. hose . .1.040. . G8.040. .5 OD x 2.875/.750MNPT x . M10 . G5 Washer. 60747 16155 60026 60495 60140 60206 60698 60205 OPTIONAL FEATURES Drain Valve: A 60774 60766 B 60365 60777 C 68327 50051 D 60205 E 60698 F 60206 G 60716 H 60144 Silent Pack: -18496 -50709 -60498 -60774 -60365 -28213 -62076 13956 D Qty 3 1 1 1 10 8 16 8 Description Washer.SAE 010 (. M10 .SAE 010 (.875/..1.0 std hex. MITSUBISHI LEFT SIDE 1 2 31 4 3 4 35 5 36 34 6 6 8 7 9 10 11 12 33 13 14 32 29 15 3 31 30 19 4 18 16 16 16 21 22 1 2 20 16 17 20 A 23 4 24 29 28 20 34 25 20 27 26 MLT4060-80K/M Parts Manual 01170 13956 D .ENGINE ASSEMBLY . fuel. element Hose. . cold weather ..8 Washer.312-18 hex.50) Hose.. 13956 D MLT4060-80K/M Parts Manual 35 . oil . 50 psi. fuel Filter.875 std hex. lower radiator hose guard Dipstick. fuel .ENGINE ASSEMBLY . crimp style Hose. M10 split lock Nut.Mitsubishi. Mitsubishi Bolt w/washer Bracket. 50 psi.312.25 x 25 std hex. G5 Element. . G5.56-2. .875/. G5 Washer.312-18 x 1. SAE 30R7 Hose.Mitsubishi Clamp. w/bracket Screw. hose .50 std hex. oil pressure 1 Kit.. air.. SAE 30R7 Fitting.750 heavy duty Bracket.188 x .SAE 032 (1. fuel .. Please contact Generac Mobile Products with questions.188 x .188 ID.312 ID.312 ID.04 ft 2 4 1 4 2 1 1 2 1 1 Description Screw. fully threaded Filter. 50 psi. G2 Washer.312 split lock Screw.312 flat . air cleaner Fan.250-20 nylock.. . black Screw. T .312-18 x . .250 split lock V-belt. G8.070 Bracket.735/. OEM warranty parts must be purchased through an OEM dealer. hose . . M6-1.250-20 x 1.black Clamp.Mitsubishi LE3 Filter. . . G5 Engine . electric Washer.0 std hex.0 x 12 pan head. fuel . . fuel .fuel filter.. 50 psi.060 Fuel pump. oil Filter. Mitsubishi Screw.04 ft . fuel filter/pump. 6kW & 8kW Notes Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. air cleaner . crimp style Hose. tubing . 60422 60026 60285 60119 16551B 60316 16589 16742 63288 60286 16692 13513 11691 11148 16691 60778 14211 14211 17145 60777 50018 60649 12838B 60256 17641 17647 50018 60144 60243 13278 60271 60393 32885 34066 61061 16444 16677 OPTIONAL FEATURES Heated Fuel Filter: A 13876 Cold Weather Belt: -10386 Qty 4 4 6 8 1 2 1 1 4 4 1 2 1 1 1 4 1. SAE 30R7 Clamp.8 Washer.188 ID. air filter Switch. heater . G8. Mitsubishi 1 Belt.MITSUBISHI LEFT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 -- Part No.250 flat ..188 barb. M10-1. SAE 30R7 Nut. hose .16 ft 1 4 1 ft 1 1 2 1 1 1.188. nylon Clamp. ENGINE ASSEMBLY .MITSUBISHI RIGHT SIDE 19 18 17 1 6 2 7 4 16 15 3 5 14 8 1 2 11 12 4 3 13 10 9 8 01171 36 MLT4060-80K/M Parts Manual 13956 D . . 2 in. engine mount .left.0 std hex.ENGINE ASSEMBLY . M8 split lock Switch. engine .500-13 x 1. . muffler Muffler.8 Washer. M8-1. oil filler Starter Isolator. battery . . wide Cable. temperature sensor Gasket. M10-1.500 split lock. SS Screw.25 hex. rubber . M10 split lock Weldment.Mitsubishi Notes Muffler.438 lug Washer. G8.8 Washer.38 in. black Alternator Nut. G5 Washer. battery . .438 lug Cable. G8.375 internal star Screw. 30 degree flare Harness. 13956 D MLT4060-80K/M Parts Manual 37 .80-200 lbs. M10-1. Mitsubishi modified Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated.right.8 Weldment. . 4GA red.. . engine mount .25 x 16 std hex.MITSUBISHI RIGHT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 -- Part No. 4GA black.24 in. black Cap. 60275 60702 60422 60026 70130B 11147 16833 15241 15074 15073 60747 60495 16554B 16743 60032 60029 16678 11042 13710 10457 OPTIONAL FEATURES Silent Pack: -34776 Qty 2 2 8 8 1 1 1 2 1 1 1 1 1 1 4 4 1 1 1 1 1 Description Screw. OEM warranty parts must be purchased through an OEM dealer. G8. Please contact Generac Mobile Products with questions.25 x 25 std hex. ENGINE ASSEMBLY .KUBOTA LEFT SIDE 29 2 23 1 28 19 27 30 25 3 27 26 4 24 5 15 22 6 23 19 21 20 8 7 6 9 19 18 10 17 19 A 18 17 11 11 12 11 13 16 B C D 15 14 38 01168 MLT4060-80K/M Parts Manual 13956 D . . Please contact Kubota Engine America Corp. 15495 60087 11628 14099 10775 60778 14211 14211 17145 13481 13515 60777 50018 13278 60393 60243 50018 62001 60271 60119 61082 60029 13483B 60285 60144 41235ZY 16589 60316 34066 16444 13310 13281 OPTIONAL FEATURES Heated Fuel Filter: A 13834 B 13682 C 10407 -10662 -13684 Qty 1 4 1 1 1 4 1. 50 psi.D1105BG Notes Gasket. hose . G2 Nut. .ENGINE ASSEMBLY .250 flat .. 50 psi.312 flat . G5 Washer.SAE 032 (1.188 barb.5 ft 1 2 4 1 ft 4 4 8 2 2 1 4 2 2 1 2 1 1 1 1 1 1 1 1 1 Description Fan. .25 std hex. V Switch. fuel filter Adapter. Kubota .312-18 x 1. . . 13956 D MLT4060-80K/M Parts Manual 39 . G8 Washer. engine Screw.188 x .070 Screw.312-18 hex. fuel Screw. Some Kubota engine parts are serial number specific. .KUBOTA LEFT SIDE Item 1 2 3 4 5 6 7 8 9 10 -- 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 Part No. G5 Spacer. Kubota .25 x 20 std hex.188 x .312 ID. oil Clamp.875/. fuel .75 OD x . . G5 Washer. SAE 30R7 Pump. 50 psi. T . fuel .50) Filter. G8. M8-1. hose .188 ID. M8 split lock Weldment.250-20 x 1. crimp style Hose. fuel .. air cleaner Clamp.inside Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated. assembly Element. heated fuel filter Heater.0 x 16 sflg hex. SAE 30R7 Hose.060 Hose.312 split lock Washer.250-20 nylock..outside Harness. crimp style Hose. or the Generac Mobile Products Technical Service Department for information regarding engine parts.188. 50 psi.17 ft 1 1 1 4 1. coolant temperature Filter.. M6-1.D1005-E3BG1-MGM-1 Engine..8 Belt.188 ID. SAE 30R7 Screw. fuel .0 std hex. filter bracket Nut. fuel filter heater . heated fuel filter Harness. air filter Engine. . OEM warranty parts must be purchased through an OEM dealer. SAE 30R7 Fitting.312 ID. . nylon Filter.735/.. air.3 ft .312.0 long Hose. hose .44 ID x 1. fuel Element.56-2. fuel filter heater . fuel filter Clamp. ENGINE ASSEMBLY .KUBOTA RIGHT SIDE 1 17 18 16 2 14 3 15 4 13 12 10 9 11 5 2 7 1 6 8 3 4 40 01169 MLT4060-80K/M Parts Manual 13956 D . engine mount Isolator.0 std hex. Some Kubota engine parts are serial number specific.25 x 25 std hex.438 in. 2 in. M8 split lock Washer. 4GA black. battery .8 Washer. coolant temperature Alternator Cap. M10 split lock Weldment.. . SS Screw. Kubota modified Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated.25 x 30 std hex Washer. G8.438 in. . . wide Cable. G5 Muffler. M10-1.38 in. . 13956 D MLT4060-80K/M Parts Manual 41 . oil filler Starter Starter Harness. M10-1. M8-1. . G8.8 Screw. OEM warranty parts must be purchased through an OEM dealer.500-13 x 1.80-200 lbs. 60422 60026 12338B 15241 15074 15073 60747 60495 63168 60029 60702 60275 13709 11042 14099 12486 12484 30582 13298 10461 OPTIONAL FEATURES Silent Pack: -36391 Qty 8 8 2 2 1 1 1 1 4 4 2 2 1 1 1 1 1 1 1 1 1 Description Screw. 4GA red.375 internal star Screw.25 x 16 std hex. lug Cable. 30 degree flare Gasket. Please contact Kubota Engine America Corp.24 in. muffler Switch.KUBOTA RIGHT SIDE Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 -- Part No.ENGINE ASSEMBLY .. battery . or the Generac Mobile Products Technical Service Department for information regarding engine parts. lug Washer. engine . rubber .Kubota Notes MLT4060K only MLT4080K only Muffler.500 split lock. GENERATOR ASSEMBLY 2 1 22 5 4 3 20 21 20 2 6 7 19 8 18 To Engine 9 17 16 15 10 14 11 12 13 42 01172 MLT4060-80K/M Parts Manual 13956 D . 25μF 550V .6kW Cover. generator Washer.375-16 x 1. generator . . SS Screw. pancake . pancake bearing . pancake .80-200 lbs.750 std hex. MLT4060K/M only Included w/item 9.75 Romex w/nut Clamp. drive .0 std hex. OEM warranty parts must be purchased through an OEM dealer. pancake case Strain relief . generator drive plate Fan. Marathon .6kW Capacitor. MLT4080K/M only MLT4060K/M only MLT4080K/M only MLT4060/80K only MLT4060/80M only MLT4060/80K only MLT4060/80M only MLT4060K/M only MLT4080K/M only MLT4060K/M only MLT4080K/M only Note: Engine and generator parts used in all Generac Mobile Products equipment carry the Original Equipment Manufacturer (OEM) warranty unless otherwise stated.25 x 16 std hex. .8kW Screw. 2 in. 13956 D MLT4060-80K/M Parts Manual 43 .8kW 9 16556 10486 15045 60206 60205 15241 60702 60275 60352 1 1 1 2 2 2 2 2 8 Generator. M8-1. MLT4060K/M only Included w/item 9. . rubber . G5 Screw. generator ..8kW -- 12328 1 Bearing. G5 Isolator. .8kW 2 3 10 11 12 13 14 15 16 17 18 19 20 21 22 --- Notes MLT4060K/M only MLT4080K/M only MLT4060/80K only MLT4060/80M only MLT4060/80M only (qty 12 only) Included w/item 9. generator . . wide Washer. Marathon .312-18 x . G5 60165 6 Screw. . pancake bearing .8kW Bracket. SS Screw. capacitor Nut.8kW Harness.6kW -- 16134 1 Bearing.500 split lock. generator .6kW Harness. 10-32 sflg Capacitor.6kW -- 11337 1 O-ring.25 x 30 std hex. M10 split lock 12327 14219 16395 61045 35132 35406 16153 16216 1 1 2 2 1 1 1 1 Cover. 25μF 440V . MLT4080K/M only Included w/item 9.5 Spacer. M10-1.0 std hex. G8. .GENERATOR ASSEMBLY Item 1 Part No. generator Seal. M8 flat 5 6 7 8 -- 11336 16123 11339 12527 12329 6 1 1 1 1 Screw.6kW Generator. G5 60494 8 Screw.375-16 x 1. .75 Plate. Please contact Generac Mobile Products with questions.SAE 6.375 split lock 60026 8 Washer.8 60206 8 Washer. G10 4 60166 18 Washer.375-24 x 1. 10-32 x 5.375 split lock Screw.50-13 x 1. 12736 11338 60398 60168 Qty 1 1 6 6 Description Cover.0 pan phil.25 std hex. FUEL TANK AND BALLAST BOXES TO UNIT 3 4 H 1 D 5 B 1 E C 15 2 16 F 14 15 6 17 D 7 7 8 9 A 10 G 11 3 4 5 12 13 44 MLT4060-80K/M Parts Manual 01480 13956 D . . . 90° . fuel tank. 50 psi. SAE 30R7 Cap. SS Tank.30 gallon tank w/sump Weatherstripping .070 Fitting.0 Screw.. G5 Washer. 3. fuel tank strap.0 in Clamp.312 barb Hose.312-18 U-clip .040. fuel tank.. . . .14.. G5 Weldment. with lanyard Replaces item 9 1 2 2 1 1 1 1 Weldment.06 x 1.312.188.5 ft 1 1 4 12 4 1 2 1 2.. large Washer.875/. fuel .5 ft Description Strap.5 dia.short type Assembly.30 gallon poly Nut.312 split lock Washer. . . fuel tank . grain diesel w/tether Tank. . 50 psi. strt .. vent. transformer Fuel pick-up tube . hose .FUEL TANK AND BALLAST BOXES TO UNIT Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Part No. fuel .0 std hex. crimp style Fitting.188 ID.312 flat . 13616B 50197 60028 60271 60119 16271 60778 14211 16326 12646 60505 62086 10656 13500 60777 15142 50018 OPTIONAL FEATURES Lanyard Fuel Cap: A 12137 56 Gallon Fuel Tank: B 12361B C 50187 D 60358 E 12359B F 60698 G 39998 H 12259 13956 D Qty 2 1 ft 16 16 16 1 2 2. strips 1 Cap. SAE 30R7 Notes Four 3 in.188 barb Clamp.375-16 nylock.250NPT x . crimp style Hose.875/.312-18 x 1.375 flat . fuel . fuel tank strap Seal. fuel .250NPT x .24 in Replaces item 1 Replaces item 2 Replaces item 11 Replaces item 1 Replaces item 11 Replaces item 10 Replaces item 14 MLT4060-80K/M Parts Manual 45 . D-shaped Nut.56 gallon Fuel pick-up tube .312-18 U-clip . hose .312 ID..long type Nut. TRAILER ASSEMBLY 1 2 3 2 4 5 7 7 10 9 24 6 25 8 27 18 28 25 21 20 26 21 19 17 9 21 24 25 7 25 10 22 24 11 23 12 13 16 11 13 15 14 01174 46 MLT4060-80K/M Parts Manual 13956 D . G5 Plate. shackle. 1360 lb Assembly. .875/. chassis.500-13 nylock. G5 Nut. G5 Jack. .0 std hex. SS Pan. . tube mount Chain. removable tongue 1 Weldment. . axle Washer.078 x 1. fuel tank Washer.820 x . compression.040.375 Nut.flat 4 to round 7 blade MLT4060-80K/M Parts Manual Notes 47 . trailer wiring .090 Coupler.TRAILER ASSEMBLY Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 Part No.500-20 lug. side wind Ring. . .0 Spring. . 60690 60698 12358B 60703 60140 11681 14326 13335B 12408Z 11682 60503 19637 60504 60096 15976 Page 50 35275 35274 35273 35272 62221 13051 23367 50215 60309 60416 16830 12420B OPTIONAL FEATURES Silent Pack: -10496B Trailer Plug Adapters: -65463 -65464 -65465 13956 D Qty 3 6 1 3 3 1 3 1 2 3 6 4 6 10 2 1 2 2 2 2 4 1 2 4 3 8 1 1 Description Screw.375 split lock. .0 std hex.057 Cotter pin .562-18 lock.375-16 hex.562-18 x 3. .416 x .. containment 1 1 1 Adapter.5 Pin. ST175/80D13. SS Washer. plunger . top wind Screw.500-13 x 4.375/.. flat 1. trailer wiring .0 std hex.090 Washer. SS Nut. G5 Jack.5 channel Weldment. . .0 ball/2. chassis Weldment.500 flat 1.375-16 x 1. shackle bracket Nut.060/. 2. top wind.375 flat .375 flat .562 x 1. G5 Wheel. retaining Weldment.flat 4 to round 7 pin Adapter. . trailer wiring . safety Screw.flat 4 to round 6 pin Adapter. outrigger Jack. G5 Washer. JACK AND HITCH OPTIONS 1 6 2 5 2 4 3 3 4 5 19 5 18 4 3 2 18 9 17 16 7 8 6 15 14 13 9 12 11 10 01175 48 MLT4060-80K/M Parts Manual 13956 D .TRAILER . lunette ring .0 channel Weldment. tube mount Cable.0 ring/2. Tube Mount Jacks: 1 11978 2 61036 3 11965Z 4 60698 5 60358 6 23254 7 23256 8 12647 Hitches: 9 12155B 10 60376 11 13003B 12 11672B 13 16835B 14 16999B 15 16741ZC 16 12229 17 50215 Qty Description 1 12 3 36 12 2 4 4 Jack.2. .3.375 flat .2000 lb. coupler Screw.375-16 nylock. G5 13956 D MLT4060-80K/M Parts Manual Notes Attaches items 11 .50 std hex.500-13 nylock.2.50 tongue Coupler. lunette ring . jack adapter Washer. . tube mount Screw. tube mount Pin.0 ball/3.31 ball/3. jack .0 channel Screw. G5 Coupler.060/. side wind . top wind . tether .375-16 x 1.875/.15 49 .625 ring/2.2000 lb. G5 18 60309 4 Washer.0 x 1.3. SS Nut.040. .5 x 1.500-13 x 4. . 2. combo hitch .50 tube Weldment. . .0 std hex. hitch . 2.TRAILER .JACK AND HITCH OPTIONS Item Part No.15 Attaches items 11 .090 19 62221 2 Nut.15 Attaches items 10 .25 std hex. SS Weldment.50 tongue Weldment.jack pin and ground rod cover 4 2 1 1 1 1 1 1 2 Spacer.500 flat 1.2000 lb. G5 Jack.0 ring/2.0 x 1.50 tongue Weldment.500-13 x 4. . AXLE ASSEMBLY 1 3 2 8 7 6 5 4 01401 50 MLT4060-80K/M Parts Manual 13956 D . wheel bearing Nut.8 51 .2200 lb Cap. U-bolt. 2200 lb Tie-plate.AXLE ASSEMBLY Item 1 2 3 4 5 6 7 8 Part No. . G8 Bolt. wheel. axle MLT4060-80K/M Parts Manual Notes Includes bearing races Items 1 . roller Assembly. 2200 lb Seal .2200 lb Bearing.500-20 wheel. U . 11206 60674 11201 12460 11203 11202 13000 11511 Qty 2 10 4 2 8 2 2 4 -- 16593 1 13956 D Description Axle hub w/studs and outer races Stud. ...........................MLT4060K/M ............MITSUBISHI Alternator .......MLT4080K/M ........................ 16687 Kubota................................................................................ engine................................................................................ radiator ... 16743 Belt....................... 14099 Switch............. 11391 Capacitor ................................. 11148 Element................................................ thermostat gasket L3E.......... 32383 Mitsubishi. 30582 Starter ................. radiator ........... 12488 Kubota.....................................................RECOMMENDED SPARE PARTS LIST (1 OF 2) ENGINE .............. engine...... 10775 Fan......................................................................................................... fan .. 17647 Element................ lights ........................................................................ 12483 Element........................................................................................... 16677 ELECTRICAL Assembly....... 16692 Dipstick ................................................................................................................................................................................................................................................................ 16691 Fan.................................... fuel filter ...........KUBOTA Alternator .. 12489 Oil fill cap ........................................ 13515 Element............................................................................................................................... 16745 Mitsubishi............................................................... 15495 Fuel shutdown solenoid.......................... oil pressure ................. radiator............................................................................................. oil filter ...........................................................................................................hard wired ........................................................................ radiator .... oil pressure ............................................... 16683 Hose........ light fixture ............................................................................................... 16742 Fuel shutdown solenoid................ 11147 Starter............................................................................................................................................................................................................................................................................. 35132 52 MLT4060-80K/M Parts Manual 13956 D ..................................... 16833 Switch....... thermostat assy L3E . radiator ............ 12486 Belt..................... 13278 ENGINE ....................................................MLT4060K ........ 14249 Bulb ...... main ............................................................................................................. 19219 Element.....quick disconnect w/cord clip ....... generator 6kW ...........upper................................. 16678 Switch................................................................. thermostat gasket D905 ......................................... thermostat assy D905 ..................................................................................................................... coolant temperature ...................................... 65959 Capacitor........................ 16688 Hose.................................................. fuel filter ................................................................................... 65963 Breaker..................MLT4080K ........................................................lower ................................................................................................................................................................................ oil filter ............................1000W MH short length ...... 13298 Switch................................................................ 13601 Breaker.................................lower ....................................... 13311 Assembly................................................. main . 13018 Hose................. fan ................ 12214 Oil fill cap ...............COMMON Cap........... 12484 Starter .................................................................................................. coolant temperature ......................................................................................................................................... light fixture ...... 16444 Fuel pump.................................... 12350 Hose.................. air filter...... 65864 Breaker.............................................................. 15375 ENGINE ................................... 11628 Dipstick ................................................................................upper.......................................... ............... ...................................... steel w/ball swedge ............... steel w/ball swedge. 65511 Transformer and cover ........................................................................... generator 8kW ...................................................... SK171 MAST Cable.................................................. 65388 Relay.. 14326 ...... SK170 Mitsubishi 2000 hour service kit .................... winch ..........................................................................188 in.................................... side wind (rear) ........................................................................... 13397 Contactor ....................................................................................................... 65049 Sensor............................................................................... 17647 Light............................................. 15085 Key ...................................................................................................................... 14798 Cable........................................................................................................ x 11 ft...................................................................................................................electric winch ..................... manual .. 15009 Cable.......................... ........................................... SK151 Kubota 2000 hour service kit ......................................... top wind (outrigger) ........................................................ 15195 LED board w/wires ......................................................... 15623 Winch.................................................... .............................................................................................................. x 16 ft......... 11681 Jack..................................no handle .... electric winch ............................. proximity .. 15309 Key switch ... retaining .............. 14130 Hour meter.......................... 14151 Handle...................................................................................................... SK152 Mitsubishi 250 hour service kit ............................... 35406 Coil cord .........................188 in........................ x 27 ft.......188 in..............w/wire 12 volt DC ............................................... 11682 Ring......... 16600 TRAILER Jack...........................RECOMMENDED SPARE PARTS LIST (2 OF 2) Capacitor....................... 10656 MAINTENANCE KITS Kubota 250 hour service kit ........................................................... indicator red ................................................................................................................. steel w/ball swedge . 11293 GFI...................... This Page Intentionally Left Blank 54 MLT4060-80K/M Parts Manual 13956 D . NOTES ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ 55 . NOTES ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ ___________________________________________________________________________ 56 .
Copyright © 2024 DOKUMEN.SITE Inc.