Deif wiring d

01 2 3 4 5 6 7 8 9 MMO MTU Friedrichshafen GmbH Maybachplatz 1 88045 Friedrichshafen Germany Tel.: +49 (0) 7541 90-0 Internet: www.mtu-online.com Revisions MMo Revision index Entry date Change description Person responsible, name, signature, date 1 2 3 4 5 b 10.11.2014 Redundarter Starter Michael Moll 117256 14 a 21.10.2014 Verkabelung XFWS1+2 geändert Michael Moll 116683 16 28.03.2014 - 28.03.2014 Remark Page 6 Michael Moll war kZ Michael Moll 0 108902 1 1 Bearbeiter 10.11.2014 Approved Checked 28.03.2014 Michael Moll Department OAS Hr.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D - 88045 Friedrichshafen Tel.:07541/ 90-3177 Fax:07541/ 903177 = + Revision Project No. X54450800010 XZ54400000074 ++ 1 Page of 0 33 0 1 2 3 4 5 6 7 8 9 MMO MTU Friedrichshafen GmbH Maybachplatz 1 88045 Friedrichshafen Germany Tel.: +49 (0) 7541 90-0 Internet: www.mtu-online.com GENSET Part list number X54450800010 Drawing number XZ54400000074 Description CIRCUIT DIAGRAM GENSET BR2000 BETA -> DEIF V2-V7 0 - 2 MTU_05 28.03.2014 war kZ 108902 Michael Moll Bearbeiter 09.05.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.05.2013 Parchmann Checked 21.05.2013 Jäger Department OAS Hr.Koliwer Maybachplatz 1 D - 88045 Friedrichshafen Tel.:07541/ 90-3177 Fax:07541/ 903177 = + Cover sheet Project No. X54450800010 XZ54400000074 ++ 1 Page of 1 33 0 1 2 3 4 5 6 7 8 9 Table of contents Plant Location Page Page description Date Name 0 Revision 10.11.2014 mollmi 1 Cover sheet 09.05.2014 mollmi 2 Table of contents 10.11.2014 mollmi 3 Switch-Cabinet Front outside 28.03.2014 mollmi 4 Switch-Cabinet Front outside 28.03.2014 mollmi 5 Mounting plate overview 01.04.2014 mollmi 6 Cabinet drilling diagram 28.03.2014 mollmi 7 Switch-cabinet rear outside 28.03.2014 mollmi 8 Legend panel 09.05.2014 mollmi 9 Clamp overview 28.03.2014 mollmi 10 Bus-overview DEIF AGC4 01.04.2014 mollmi 11 AGC 4 Digital Generator Control 10.11.2014 mollmi 12 Generator Signal Automatic voltage regulator 09.05.2014 mollmi 13 Generator winding and bearing temperature 01.04.2014 mollmi 14 Power unit battery + starter 10.11.2014 mollmi 15 Water heater 3PH or 2PH 01.04.2014 mollmi 16 Fuel water separator 1-4 21.10.2014 mollmi 17 Engine control unit ADEC ECU9 Plug -X1 10.11.2014 mollmi 18 Supply 24VDC Charger 10.11.2014 mollmi 19 Supply 24VDC Charger 01.04.2014 mollmi 20 A300 01.04.2014 mollmi 21 GCB-Generator circuit breaker 01.04.2014 mollmi 22 MCB-Mains circuit breaker 28.03.2014 mollmi 23 FAN-Engine fan 28.03.2014 mollmi 24 Spare terminal 10.07.2014 mollmi 25 Spare terminal 10.07.2014 mollmi 26 Bill of material 09.05.2014 mollmi 26.a Bill of material 10.11.2014 mollmi 26.b Bill of material 10.11.2014 mollmi 26.c Bill of material 10.11.2014 mollmi 26.d Bill of material 10.11.2014 mollmi 26.e Bill of material 10.11.2014 mollmi 26.f Bill of material 10.11.2014 mollmi X 1 3 Bearbeiter 10.11.2014 Approved Checked Department OAS Hr.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D - 88045 Friedrichshafen Tel.:07541/ 90-3177 Fax:07541/ 903177 = + Table of contents Project No. X54450800010 XZ54400000074 ++ 1 Page of 2 33 05. X54450800010 XZ54400000074 ++ 3 Page of 3 33 .05.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2013 Jaeger Department OAS Hr.Koliwer Maybachplatz 1 D .:07541/ 90-3177 Fax:07541/ 903177 Switch-Cabinet Front outside = + Project No.2013 Parchmann Checked 21.1 2 3 4 5 6 7 8 9 EMERGENCY STOP 0 2 4 Bearbeiter 28.88045 Friedrichshafen Tel.03. 8 20 18 173 66 239 241.0 1 2 3 4 5 6 7 8 9 22. X54450800010 XZ54400000074 ++ 3 Page of 4 33 .05.5 400 500 3 5 Bearbeiter 28.05.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.Koliwer Maybachplatz 1 D .:07541/ 90-3177 Fax:07541/ 903177 Switch-Cabinet Front outside = + Project No.3 22.2013 Parchmann Checked 21.3 24.1 300 350 250 204 96 Frontdoor 50.3 Door cut-out 219.5 1000 600 2.88045 Friedrichshafen Tel.2 22.03.2013 Jaeger Department OAS Hr. 1 2 3 4 5 6 7 8 6 7 5 17 4 3 3X03 1 2 3X02 X02 X02 182 N 3 2 1 N 6 5 4 MZ2 MZ1 MY2 MY1 MX2 MX1 M- N L3 L2 L1 30 162 26 290 SIEMENS 5SY_1 4X01 3X01 2X01 1X01 GCB A1 C O I L CABLE DUCT 80x40 A2 14 N O 24 11 C O M N O 24 21 14 SIEMENS 5SY_1 5X01 355 SIEMENS SIEMENS 5SY_1 X03 6X01 Option 97 133 72 +A300 36 21 C 11 O M N Slot#8 126 Slot#6 14 B3 A3 B1 90 N O 24 A2 C O I L Geno Engine A1 85 Slot#5 89 14 124 A1 Display 65 64 Slot#4 29 28 Slot#2 O 24 514 11 446 12 Shield 13 14 CABLE DUCT 80x80 Geno 15 16 539 SIEMENS SIEMENS 5SY_1 SIEMENS 28 MCB 380 SIEMENS 32 SIEMENS 5SY_1 8 9 111 SIEMENS 34 CABLE DUCT 80x25 SIEMENS 5SY_1 40 29 27 25 24 42 40 36 SIEMENS SIEMENS 5SY_1 35 33 10 GND 6mm² M8 Harness Door CABLE DUCT 80x40 9 222 0 X07 1X02 X06 X05 X04 39 Service port XMOD DIASYS USB 84 117 Slot#5 116 Slot#7 Spare X7 X5 78 Slot#5 98 73 DEIF Slot#1 Slot#3 37 1- 20 ECU 41 Smart Connect 79 51 50 Ethernet 15 14 CABLE DUCT 80x25 X1 X2 X3 X4 POWER RS485 CAN1 CAN2 3 2 1 3 2 1 3 2 1 3 2 1 CABLE DUCT 80x25 M8 GND 6mm² 50 130 337 555 760 785 871 955 4 6 Bearbeiter 10.2013 Parchmann Checked 21.:07541/ 90-3177 Fax:07541/ 903177 Mounting plate overview = + Project No.88045 Friedrichshafen Tel.Koliwer Maybachplatz 1 D .2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.05. X54450800010 XZ54400000074 ++ 3 Page of 5 33 .2013 Jaeger Department OAS Hr.05.11. 4mm 2. ECU W001 Harness NW 22 7. GENO W003 Harness NW29 5.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21. GENO W007 Harness NW29 4. Engine W002 Harness NW22 6. MCB Oelflex 14x 1mm² 5 7 Bearbeiter 28.5mm² 3. X54450800010 XZ54400000074 ++ 2 Page of 6 33 .88045 Friedrichshafen Tel. GCB Oelflex 2x2.:07541/ 90-3177 Fax:07541/ 903177 Cabinet drilling diagram = + Project No.05.2013 Parchmann Checked 21.0 1 2 3 4 5 6 7 8 9 600 mm M8 bolt M25 / NW=22 7 M25 / NW=22 6 25 25 Spare ECU W001 Engine W002 32 M32 / NW=29 M32 / NW=29 Rubber cable grommets 1xM20 Rubber cable grommets 1xM20 50 4 3 32 Geno W003 50 2 32 Geno W007 50 50 1 M8 bolt 20 20 GCB WTB4 MCB WTB5 14 50 60 50 M32 25 5 20 14 M25 16 114 Rubber cable grommets 1xM20 M16 16 70 M16 250 Rubber cable grommets 2xM16/1xM25/1xM32 1.Koliwer Maybachplatz 1 D .03.2013 Jäger Department OAS Hr.05. GCB Oelflex 14x1mm² 11. 05.2013 Jäger Department OAS Hr.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21. X54450800010 XZ54400000074 ++ 3 Page of 7 33 .05.2013 Parchmann Checked 21.03.:07541/ 90-3177 Fax:07541/ 903177 Switch-cabinet rear outside = + Project No.88045 Friedrichshafen Tel.Koliwer Maybachplatz 1 D .0 1 2 3 4 5 6 7 8 9 1000 960 20 20 20 9 9 20 560 9 600 Hole 9mm 9 6 8 Bearbeiter 28. 0000 Finder GmbH Relais 24V DC 2C 8A 7 9 Bearbeiter 09.52. X54450800010 XZ54400000074 ++ 1 Page of 8 33 .05.9.88045 Friedrichshafen Tel.current switch 1NO+1NC circuit-breaker C40A/10kVA 1pol Aux.024. item designation 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 20 24 25 26 27 28 29 30 32 33 34 35 36 39 40 41 42 -X01 -X02 -3X02 -3X03 -1X01 -2X01 -3X01 -4X01 -5X01 -6X01 -X04 -X05 -X06 -1X02 -X07 -XMOD -X03 -TB10 -FC1 -FC2 -FC2 -FC3 -FC3 -FC4 -FC4 -FC5 -FC6 -FC6 -FC7 -FC7 -AF20 -FC5 -AF12 -KF1 manufacturer No. manufacturer Designation SDR-960-24 5SY4106-7 5SY4110-7 5ST3010 5SY4110-7 5ST3010 5SY4106-7 5ST3010 5ST3010 5SY4125-7 5ST3010 5SY4140-7 5ST3010 X59434200175 5SY4120-7 Mean Well Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Siemens AG Deif A/S Siemens AG Single-phase power supply 230V/ 24VDC/ 40A.0 1 2 3 4 5 6 7 8 9 Legend panel Pos-Nr.current switch 1NO+1NC Digital Genset Controller V2-6 Circuit-breaker C20A/10kVA 1pol 40.current switch 1NO+1NC circuit-breaker C6A/10kVA 1pol Aux. circuit-breaker C6A/10kVA 1pol circuit-breaker C10A/10kVA 1pol Aux.:07541/ 90-3177 Fax:07541/ 903177 = + Legend panel Project No.current switch 1NO+1NC Aux.current switch 1NO+1NC circuit-breaker C25A/10kVA 1pol Aux.2014 Approved Checked Department OAS Hr.current switch 1NO+1NC circuit-breaker C10A/10kVA 1pol Aux.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . 05.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.88045 Friedrichshafen Tel. X54450800010 3038558 3022218 3038516 X05 = + XZ54400000074 3202575 3031843 3212154 3212139 3212154 3212139 3212154 3212139 3031306 3212139 3035974 1x Prüfadapter or 8 8 Page of 1201442 1201468 X02 3030857 3030844 N 3 2 1 N 6 5 4 N L3 L2 L1 3X02 3030857 3212167 3030857 3212167 3030514 3030857 3212167 MZ2 MZ1 MY2 MY1 MX2 MX1 M- 3035980 3x Prüfadapter sw 3036110 3031306 7 3038558 3030747 X06 3038516 3038516 3038532 1201442 3212167 3035755 3036644 3022218 3X03 3030174 3030174 1X02 3038558 3030747 X07 3030514 3031306 3031306 3031306 3031306 3036110 6 3022218 3038516 3030815 3030815 3030815 3030815 3030815 3030514 5 3038558 3022218 XMOD 3038558 3030747 3022218 3022218 3031241 4 3030488 3022218 3031306 3036110 3 3036644 3031500 3038516 2 3022218 2X01 3038558 3022218 3X01 3038558 3030747 4X01 3038516 3038516 3038516 3038532 3038532 3038516 3038532 1 3038558 3030747 5X01 3038558 3030747 6X01 3038558 3030747 3038558 3030747 3022218 0 9 X02 1X01 X03 X04 ++ 10 1.2013 Parchmann Checked 21.5 9 33 .05.Koliwer Maybachplatz 1 D .Bearbeiter 28.:07541/ 90-3177 Fax:07541/ 903177 Clamp overview Project No.03.2013 Jäger Department OAS Hr. 2 /11.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.34 mm² X3 CAN2 (L) CAN2 GND CAN2 (H) CAN1 GND 3 X4 1 2 3 X5 .34 mm² HI -WCAN_01 SH 120Ω * GND UNITRONIC 3x0. X54450800010 XZ54400000074 ++ 1 Page of 10 33 .88045 Friedrichshafen Tel.2 /11.0 1 2 3 4 5 6 7 8 9 Bus-overview DEIF AGC4 -AF20 Automatic Genset Controller /11.04.2 / 0124 4 CAN2 CAN2 GND 3 3 3 CAN2 (L) 2 2 CAN2 (H) 1 1 CAN1 CAN1 GND X2 RS485 GND 3 RS485 (A) 0VDC 2 RS485 (B) 24VDC 1 3 GNYE 1.2 HI A1 CAN_L /11.34 mm² 18.0 X1 1 2 5 CAN 1-Interface 3 4 1 1 0 8 CAN 2-Interface Engine control unit ADEC ECU9 Plug -X1 1 2 0 1 3 0 free BN Frequency BK SH GND WH LO HI SH GND BN Variante Dip switch Baureihe 120Ω Terminating resistor included in the plug BK 120Ω WH LO HI Default setting for BASLER DGC Droop 18.2 / 0924 1 8 00000000 BR2000 V1 11100000 BR2000 V2-6 Speed demand +ENG -KF3 /17.:07541/ 90-3177 Fax:07541/ 903177 Bus-overview DEIF AGC4 = + Project No.2 Slot#8 COM CAN_H /11.2013 Jäger Department OAS Hr.5 mm² X1 GND RS485 CAN1 (L) X4 2 CAN1 (L) X3 1 CAN1 (H) X2 X1 +A300 -XMOD Smart connect CAN1 (H) -AF12 X5 X7 5 6 Reserved for internal use 4/0% 4 7 8 0/4% 50Hz 9 11 Bearbeiter 01.2 /11. USB 2 DIASYS 1 SH * X7:.2 /11.2 130 WH BN SH SH A3 LO A2 COM CAN_H /11.05.2 131 132 133 UNITRONIC 2x0.2 /11.05.2 B1 B2 120Ω B3 120Ω 128 -WCAN_2 129 CAN_L /11.1 AGC-4 CAN-BUS 3 CAN_H1 COM CAN_L1 CAN_H2 COM CAN_L2 /11. Terminating resistor at the end of the Bus system SH BK BN SH -WCAN_02 SH WH GND SH SH LO BN HI BK GND WH LO UNITRONIC 3x0.2 /11.2013 Parchmann Checked 21.Koliwer Maybachplatz 1 D .2 /11. 2013 Jaeger Department OAS Hr. in.1 38 COM 2 /24.4 COM Busbar voltage L1 117 118 Busbar voltage L2 119 Busbar voltage N Busbar voltage L3 121 /24.1 SLOT2 2 SLOT3 1 SLOT4 0 /24./ outputs 3 #3 Terminal 37-64 . Engine I/F 2 #2 Terminal 29-36 .7 /21.6 Floating load /24.8 SLOT6 Engine start /12.0 40 122 18.6 29 COM Fuel Transfer Pump 0144 / 18. S2 (l) L1 AC current 100 MPU input CAN_H 1 Page S1 (k) L1 AC current 64 COM /12. Engine communication .8 /20.4 Relay 11 14 52 56 /14./ outputs 5 #5 Terminal 73-89 . Slot 1 #1 Terminal 1-28 .2 43 GCB tripped 7 /21.2 /13.4 / 0142 COM /12. AC measuring 6 #6 Terminal 90-97 .4 / 0943 COM for 112-117 /12.3 /22.11.1 Remote Start /24.1 89 COM 42 Ext.4 50 Spare Spare Spare 16 53 Spare A3 B1 B2 B3 128 129 130 131 Bearing 1 KGS -NDE temp /13. X54450800010 XZ54400000074 ++ 1 Page of 11 33 .3 4 (+) 8-36VDC (-) common for 118 18.5 Safety System Override /24.2014 Michael Moll MTU Friedrichshafen GmbH Approved 07.7 48 COM /20.4 81 82 Busbar voltage L3 112 114 C 80 109 113 79 Busbar voltage N /12./ outputs / load sharing 9 LED I/F 4 #4 Terminal 65-72 .1 0911 / 18.2 39 Reactive load sharing /20.1 CAN_GND 1 DEIF DEIF CAN_L 1 DEIF /10.2 CAN_L 2 /10.1 26 GCB opened /21.5 84 F Spare Spare /10.1 CAN_H 2 /10.2 /12.0 86 /24.7 91 COM /13.1 65 Auxiliary Input /12. PF/VAr /V set point 6 /21.6 46 Fuel water separator 2 10 /24.1 87 /24.7 Blocking synch.7 Batt - 12 B 9 Batt + Auxilary CB/Failure /23.4 MCB open 49 124 90 Relay 05 MCB close 62 /13. in.3 44 GCB charged 8 /16.4 /13.3 CAN_H ECU /10.6 57 21 Changeover switch starter 0141 / 18.7 23 Auxalary CB tripped /22.4 COM 133 Slot No.5 Fixed load /24.7 75 S1 (k) L3 AC current 116 Local genset release /12. /24.2 CAN_L ECU /10.4 COM /10. Governor .3 CAN_L /10.3 47 Day tank no leakage /23.3 28 /23.3 COM /22.2 Engine stop /14.2 0133 / 18.6 Winding temp 3A /13. AVR .2013 Parchmann Checked 07.1 66 30 31 General fault red 32 COM 33 General alarm yellow 34 COM 35 Daytank control 36 COM COM 94 Day tank 95 67 COM 96 68 Room temp. 97 /23.5 15 63 A2 COM Relay 08 13 51 0933 / 18.2 /13.3 COM ECU /10.5 83 /12. Communication 8 #8 Terminal 126-133 .8 92 Bearing 2 KS -DE temp /13.01.2 11 123 A1 Ext.1 88 /24.5 /21.3 /13. In.Koliwer Maybachplatz 1 D .4 /13. kW / Hz set point 41 115 85 8 Page - /24.6 Emergency stop /17.7 78 AGC 4 Connection overview 104 AGC-4 Daten 105 106 107 Busbar voltage L1 /12.3 Spare 18 55 Spare 19 COM 20 0161 / 18. External protection trip. Power supply 7 #7 Terminal 98-125 .1 /15.4 59 60 COM 61 Coolant Fan 1 COM Coolant Fan 2 COM Relay 14 GCB close COM Relay 17 Only 10mA output Spare Spare 22 COM /19.6 /13.8 93 /23.:07541/ 90-3177 Fax:07541/ 903177 AGC 4 Digital Generator Control = + Project No.7 /24.4 / 0931 99 S1 (k) L2 AC current 101 /13.1 24 MCB opened /22.7 76 S2 (l) L3 AC current 120 Engine start prepare /12.01.2 / 0113 18.4 37 Active load sharing 1 /24.0 /24.4 Winding temp 2A /13.0 0152 / 18.2 /10.2 Not used 69 70 SLOT8 -AF20 98 6 SLOT1 Page - 5 Fuel Cooler /24.1 27 GCB Closed COM Room fan on /Louver GCB open 17 54 58 /23.2 CAN_GND 2 /10.4 108 110 Busbar voltage L2 /12.2 45 Fuel water separator 1 9 /16.7 77 SLOT7 Winding temp 1A S2 (l) L2 AC current 7 Page 73 102 SLOT5 MPU GND No. In.88045 Friedrichshafen Tel.8 5 Horn 0143 / 18./ outputs 10 12 Bearbeiter 10.7 74 103 111 18.5 4 Status Relay /19.4 CAN_H /10.3 3 Status Relay /20.4 Relay 69 71 Engine start prepare 72 Relay 71 132 /24.1 25 MCB Closed /21.3 AGC4 / 18. 2013 Parchmann Checked 21.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.Koliwer Maybachplatz 1 D .2 84 GND 74 IA- 73 IA+ 76 IB- 75 IB+ 78 IC- 77 IC+ +A300-AF20 AGC4 AGC4 Auxiliary Input /11.2 65 79 GEN VA 81 N 83 -3X03 MY2 WH MX2 WH MZ2 WH MZ1 3 MZ2 2 MY1 1 MY2 -3X02 MX2 8 WH 7 1² / 17AWG 6 WH 5 1² / 17AWG 4 WH 3 1² / 17AWG 2 WH 1 1² / 17AWG -3X01 GND Switching jumper M- MX1 W003 -W03/1 x IB+ 3X01:1 WH 1²/17AWG x x MY1 WH x x 2.:07541/ 90-3177 Fax:07541/ 903177 Generator Signal Automatic voltage regulator = + Project No.5² / 13AWG x IA- x GND x N x L3 Auxiliary input negativ x L1 Auxiliary input positiv x Geno terminal box x IA+ Current measurement Generator Sensing Output Control generator L2 /13.1 Busbar voltage L1 AGC4 S2 (l) L1 AC current 11 13 Bearbeiter 10.11.2 66 18.5² / 13AWG x IB- x GND x MX1 WH x Power supply x 2.5² / AWG 15 2.5² / 13AWG 3X01:3 WH 1²/17AWG 1 x IC- 3X01:2 WH 1²/17AWG W003 -3X03 0123 0923 18.0 1 2 +GENO 3 4 5 6 7 8 9 DVR 3X01:6 WH 1²/17AWG 3X01:7 WH 1²/17AWG 3X01:8 WH 1²/17AWG 3X01:9 WH 1²/17AWG 3X01:10 WH 1²/17AWG 0VDC GND N 4 GNYE MX2 WH 3 5x1.05.88045 Friedrichshafen Tel.2013 Jäger Department OAS Hr. X54450800010 XZ54400000074 ++ 1 Page of 12 33 .05.5² / 13AWG 24VDC IC+ 3X01:5 WH 1²/17AWG -GENO MZ1 WH 3X01:4 WH 1²/17AWG 2 x 2. 2A Winding temp.34²/22AWG LIYCY 3x0.05. 1A Winding temp.2013 Jäger Department OAS Hr.1 temp /11.0 1 2 3 4 5 6 7 8 9 +CUS Customer Winding temp 1A Power 230V 1000W Fuse 16A/10kA AGC4 AGC4 AGC4 AGC4 AGC4 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 L N 104 GND 103 Winding temp 2A /11.34²/22AWG LIYCY 3x0.0 H1 H2 GENO-HEATER L1 L2 L3 Winding temp.34²/22AWG WH BN GN WH BN GN WH BN GN SH -WBT08 WH BN GN LIYCY 3x0.1 105 110 109 Bearing 1 KGS -NDE /11.08-4.1 temp 90 93 92 Danger SH Customer 3x2.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.3 Amp.05. Fuse C16A/10kA 12 14 Bearbeiter 01.04.Koliwer Maybachplatz 1 D .2013 Parchmann Checked 21.88045 Friedrichshafen Tel.500-1000W / 2. 3A Bearing 1 KGS -NDE temp Bearing 2 KS -DE temp +GEN-EB1 OPTION Option Danger Power 230V .34²/22AWG WH BN GN W007 x x +GENO x x x x x x x x x x x x x x x /12.:07541/ 90-3177 Fax:07541/ 903177 Generator winding and bearing temperature = + Project No. X54450800010 XZ54400000074 ++ 1 Page of 13 33 .34²/22AWG LIYCY 3x0.1 102 107 106 Winding temp 3A /11.5²/ 13AWG SH SH SH -WBT01 -WBT02 -WBT03 -WBT07 LIYCY 3x0.1 108 91 Bearing 2 KS -DE /11. 2 11 /14.5² / 15AWG 2 A2 0932 / 18.88045 Friedrichshafen Tel.05.1 9 Changeover switch starter /11.2014 Redundarter Starter 117256 Michael Moll Bearbeiter 13.05.013.0 B OPTION - M A Engine start (A) +ENG-QA1 13 b 15 10.11.2013 Parchmann Checked 21.013.0 1 2 3 4 5 6 7 AGC4:121 WH 1² 11 +A300-V1 57 14 2 3 +A300-KF2 * A1 +A300-KF2 24VDC WH 1² Option x2 x1 0921 DBU / WH 1.4 Only at redundatem starter * +A300 -2X01 +A300-AF20 WH 1² +A300 -2X01 121 AGC4 0921.11.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.1 x2 START 8 14 12 24 22 0921 / 18.2013 Jäger Department OAS Hr.12 75A/18-32VDC 30 WG2/1+ 2X01:2 WH 1 95² / 3/0AWG GA+ 6 mm² C 0912 A2 - 0914 A1 1 mm² ws 2X01:3 WH 1²/17AWG BK 6 mm² RD 30 50 - +ENG-QA2 31 + +ENG-GB1 M Engine start (B) / 18.0 BAT- W002 + 95² / 3/0AWG 2 - + Pilot Relais (B) + +ENG-KF2 12V + 12V 1 A1 29.2 BAT+ / 18.:07541/ 90-3177 Fax:07541/ 903177 Power unit battery + starter = + Project No.12 75A/18-32VDC Pilot Relais (A) +ENG-KF1 Battery 31 50 + 1²/17AWG A2 1 mm² ws C GA+ 6 mm² 1x95 mm² 6 mm² BK 95² / 3/0AWG + 95² / 3/0AWG RD WG2/1- 1x95 mm² 2 29.7 AGC4 x1 1.5² / 15AWG +A300-KF2 /11. / WH 1² 12 WH 1² +A300-AF20 0921 DBU / WH 1N4007 /14.Koliwer Maybachplatz 1 D .2 0914 / 18. X54450800010 XZ54400000074 ++ 1 Page of 14 33 .5 21 No start +A300-V1 3 1N4007 0912 / 18. 5² / 15AWG -XEB1 1²/17AWG Danger 1. 2500W 230V 10.Koliwer Maybachplatz 1 D .8A Fuse C16A/10kA Wire-Ölflex 3x2.5² / 15AWG 1.6A Fuse C16A/10kA Wire-Ölflex 4x2.05.4 L x2 GND 0944 DBU / WH 2X01:1 WH 1.5² / 15AWG 1. 6000W 400V 8. X54450800010 XZ54400000074 ++ 1 Page of 15 33 .Cooling Water (B) OPTION +ENG-EB1 400V/50Hz DANGER Power 1-PH.2 1N4007 18.1 +CUS AGC4 +A300-AF20 Customer R2-A WH 1² / 17AWG 71 +A300 -2X01 L x1 0922 DBU / WH 1² / 17AWG 1 0922 / 18.05.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2013 Jäger Department OAS Hr.0 1 2 3 4 5 6 7 8 9 Engine start prepare /11.88045 Friedrichshafen Tel.5²/13AWG Power 3-PH.:07541/ 90-3177 Fax:07541/ 903177 Water heater 3PH or 2PH = + Project No.5²/13AWG max.5² / 15AWG 0944 / L +A300-V2 1 0944 4 2 1 3 2 2X01:1 Customer GND L1 L2(N) L3(x) A1 A2 Water Heating .2013 Parchmann Checked 21.5² / 15AWG 1. 20m 14 16 Bearbeiter 01.04. 5² / 15AWG 0962 / 18.1 +ENG-BM1.10.05.1 +ENG-BM2.1 +A300-AF20 1.1 AGC4 AGC4 +A300-AF20 2X01:5 WH 46 1² / 17AWG +A300 -2X01 5 0963 / 18.2013 Parchmann Checked 21.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2014 Verkabelung XFWS1+2 geändert 116683 Michael Moll Bearbeiter 21.2 3 4 5 6 7 Fuel water separator 1 /11.5² / 15AWG 8 1² / 17AWG 1 09xx Pin 2 1²/17AWG 0 Bridge to pin 3 5 7 3 4 6 7 3 1 2X01:4 -516Pin 4 4 Pin 7 1 2 3 4 5 6 7 6 5 2 01xx Pin 5+6 5 3 4 2 2 5 4 5 + 2 - 7 4 6 6 5 5 7 6 7 3 3 -XFWS2 2 2 +ENG -XFWS1 1 2 3 4 5 6 7 7 6 S + 3 - 2 7 6 3 4 4 S + - S + - S Fuel water separator 1.2 Minus switching PLCA 50DC Minus switching PLCA 50DC Minus switching PLCA 50DC Minus switching PLCA 50DC +ENG-BM1. X54450800010 XZ54400000074 ++ 1 Page of 16 33 .2013 Jäger Department OAS Hr.6 0162 / 18.2 +ENG-BM2.:07541/ 90-3177 Fax:07541/ 903177 = + Fuel water separator 1-4 Project No.2 Fuel water separator 2.2 Option 15 a 17 21.Koliwer Maybachplatz 1 D .88045 Friedrichshafen Tel.1 Fuel water separator 2.6 0163 / 18.5² / 15AWG 2X01:4 WH 45 0962 DBU / WH 9 Fuel water separator 2 /11.6 0163 DBU 2X01:5 WH 2X01:4 WH W002 1²/17AWG W002 1.05.1 Fuel water separator 1.10.6 0963 DBU / WH 0162 DBU 4 1.5² / 15AWG +A300 -2X01 1. 51 0981 9 44 ECU 9 Engine control unit ECU9 Plug -X1 0V 40 Analog out 19 16 1X01:10 WH 1²/17AWG 46 -WECU_02 1X01:9 WH 1²/17AWG +ENG -KF3 1X01:7 WH 1²/17AWG 1X01:8 WH 1²/17AWG W001 -X3- -X3+ 19.2012 Parchmann Checked 12.:07541/ 90-3177 Fax:07541/ 903177 Engine control unit ADEC ECU9 Plug -X1 = + Project No.0 1 2 3 4 5 8 9 1 +A300 -SF3 Only at redundatem starter 7 * AGC4:119 +A300-SF3 Option 6 2 Injection interruption 1 Engine Stop /11.2 +A300 -1X01 2 3 4 5 9 10 Spare 19. X54450800010 XZ54400000074 ++ 1 Page of 17 33 .2 -X1/2 19.6 E-Stop +A300 -X06 119 1² / 17AWG WH X06:4 21 +A300 -SF1 +A300-AF20 22 3 4 7 1 Bridge 3 4 21 +CUS -SF2 * 8 5 x +CUS -WSNA1 -1X01 6 Spare 22 External customer 6 11 12 1 2 3 WH BN GN -1X02 SH 34 option /10.2 10 1X01:12 WH 1²/17AWG 1X01:11 WH 1²/17AWG 1X01:6 WH 1²/17AWG 1X01:1 WH 1²/17AWG 42 31 input CY 3x0.2012 Jäger Department OAS Hr.5² / 13AWG 0971 0972 0973 18 14 1X01:5 WH 1²/17AWG 0513 DBU 2.5² / 13AWG 0973 DBU / WH 2.Koliwer Maybachplatz 1 D .5² / 13AWG 0513 Start 1X01:4 WH 1²/17AWG 0512 DBU 2.12.2014 Michael Moll MTU Friedrichshafen GmbH Approved 12.11.3 W001 16 18 Bearbeiter 10.5² / 13AWG 0512 26 1X01:3 WH 1²/17AWG 0511 DBU 2.5² / 13AWG 0511 30 1X01:2 WH 1²/17AWG 0993 DBU / WH 1² / 17AWG 61 0993 60 0992 DBU / WH 1² / 17AWG 57 0992 62 0994 DBU / WH 1² / 17AWG 59 0994 58 0984 13 0984 DBU / WH 1² / 17AWG 17 0983 DBU / WH 1² / 17AWG 29 0983 25 option 0V 0981 DBU / WH 1² / 17AWG 33 24 V Pot.34 / 22AWG 32 39 43 35 E-stop 0971 DBU / WH 2.88045 Friedrichshafen Tel.1 AGC4 /21.5² / 13AWG 0972 DBU / WH 2.12. 8 9- 10² Fixed bridge 0V BAT6² / 9AWG BK 1 3 -X03 9.0 /19.7 C6A 14 -FC3 9 24V+ / 19.1 21 1 14 21 2 13 22 -FC5 2 14 C20A 22 2.0 0162 / 16.7 0913 / 19.0² / 9AWG GNYE 6.0² / 11AWG GNYE 4.0 0154 / 22.7 0142 / 11.0² / 9AWG GNYE 4.3 0923 / 12.3 0931 / 11.05.1 2 0V.:07541/ 90-3177 Fax:07541/ 903177 = + Supply 24VDC Charger Project No.7 0 11.2013 Jäger Department OAS Hr.2 0921 / 14.0 0952 / 20.2 0933 / 11.88045 Friedrichshafen Tel.6 0143 / 11.3 -X03 1.6 0163 / 16.11. X54450800010 XZ54400000074 ++ 1 Page of 18 33 .2 6² / 9AWG RD -X03 AGC4 13 22 C6A -X03 1.0 0962 / 16.4 0941 / 19.4 -X03 9.7 0914 / 14.0² / 11AWG GND 0V potential w/ with H05V-K 15AWG DBU-WH GND GND ground bolt M8x25 GND GNYE 6.5² / 16AWG FC3 DBU 2.3 0953 / 21.8 0943 / 11.9 0912 / 14.9 / BAT+ 14.3 0133 / 11.1 13 -FC4 /19.3 0924 / 10.7 0161 / 11.3 0141 / 11.05.2 0944 / 15.0² / 9AWG GND GND ground bolt M8x25 GNYE 6.0 0954 / 22.Koliwer Maybachplatz 1 D .1 0911 / 11.1 2 Automatic Genset Controller 3 4 General 5 Digital output 6 Digital input Fixed bridge 1 13 1 21 -FC2 C10A 2 14 C10A 22 2 DBU -X03 1.9 / BAT- 0113 / 11.9 -X03 9.5 4 0932 / 14.5² / 16AWG FC1 -X03 1.7 0963 / 16.3 0124 / 10.3 -X03 9.7 0964 / 23.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2013 Parchmann Checked 21.7 0153 / 21.6 -X03 9.0² / 9AWG -X03 Shield SH 17 19 Bearbeiter 10.2 -X03 1./ 19.4 0132 / 20.6 1+ 10² 14.7 2 1 21 /19.5² / 16AWG FC2 DBU 2.6 -X03 1.4 -X03 9.7 0164 / 23.5 -X03 1.1 0922 / 15.7 -X03 1.7 0144 / 11.7 1 -FC1 BAT+ 8 Generator Ciruit Breaker 24V -X03 7 /19.2 0123 / 12.0 Terminals legend Mounting panel Front door -X03 GND 9- 10² GNYE 6.0 0152 / 11. 4A -Fuse C16A/10kA .5² / 13AWG 2.1 SDR-960-24 -V -V 0513 L 0511 +V -FC5 /18.05.9 1² / 17AWG 17.2 14 0913 DBU / WH 3x1.1 2 3 4 5 6 8 Auxalary CB tripped /11.4 18.2 -X03 9.1 18 20 Bearbeiter 01.5² / 13AWG 0991 DBU / WH 2.88045 Friedrichshafen Tel.5² / 13AWG 0972 DBU / WH 0V- 2.04.7V 24V 13 13 0941 DBU -PJ1 /19.8 / +GENO-CUS X3- Power 230VAC .8 / 24V+ 7 1² / 17AWG 0 13 13 Danger -FC2 -X01 X3+ L N GND /18.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.1.5² / 13AWG 0511 DBU 2.0² / 9AWG FC5 0982 DBU / WH -FC7 2.05.7 Mean Well SDR-960-24 Battery Charger W001 0512 +V Horn Horn 0V 24V AC AC /18.5 6.7 /19.5² / 13AWG FC6 C40A 19.5² / 13AWG -TB10 14 14 x2 0941 DBU / WH -FC6 51 960W/24V/40A ADJ Range 26.2 / 0982 x1 /19.5² / 13AWG 0991 DBU / WH 14 51 1² / 17AWG -FC7 C25A 1² / 17AWG -FC6 1 9 +A300-AF20 FC7:14 WH 18.3 17.7 0993 DBU / WH 1² / 17AWG 0994 DBU / WH 1² / 17AWG 0992 DBU / WH 1² / 17AWG 0981 DBU / WH 1² / 17AWG 0983 DBU / WH 1² / 17AWG 0984 DBU / WH W001 1² / 17AWG 0971 DBU / WH 2.6 GND -FC3 13 13 -FC4 N 14 14 /18.4 9.:07541/ 90-3177 Fax:07541/ 903177 = + Supply 24VDC Charger Project No. X54450800010 XZ54400000074 ++ 1 Page of 19 33 .4 0513 DBU 2.7 WH 2005 DBU 2.5²/15AWG 0993 0994 0992 0981 0983 0984 0971 0973 0972 W001 0913 L1 18.5² / 13AWG 18.2013 Jäger Department OAS Hr.1 AGC4 AGC4 +A300-AF20 5 23 /19.8 Customer 0982 / 19.5² / 13AWG 0512 DBU 2.Wire 3x1.1 ECU 24VDC Fixed bridge 1 13 21 2 14 22 14 21 2 13 22 Horn /11.5² / 13AWG 0973 DBU / WH 0VDC 2.2 -X1/2 17.2013 Parchmann Checked 21.Koliwer Maybachplatz 1 D .5²/15 AWG N PE 9. 1 +A300-AF20 0132 / 18.2014 Michael Moll MTU Friedrichshafen GmbH Approved 12.04.4 Remote Start /11.1 14 +A300-KF1 /20.6 E-Stop 1² / 17AWG WH X06:6 1.2012 Jäger Department OAS Hr.12.1 11 GND +A300-KF1 A1 +A300 -X06 A2 15 GND 21 +CUS -WSNA1 Remote Control Start ATS 14 12 24 22 7 x Bridge 24VDC +A300 -X04 6 5 6 GND 31 +CUS -SF2 GND 32 External customer 11 /20.12.1 21 19 21 Bearbeiter 01. X54450800010 XZ54400000074 ++ 1 Page of 20 33 .2012 Parchmann Checked 12.6 AGC4 +A300-AF20 / 18.5² / 15AWG 0952 DBU / WH 12 Emergency Stop /11.1 1² / 17AWG 0952 1² / 17AWG WH KF1:31 49 Status Relay /11.:07541/ 90-3177 Fax:07541/ 903177 = + A300 Project No.1 AGC4 AGC4 AGC4 +A300-AF20 +A300-AF20 OUT 3 0132 DBU OUT 4 IN 118 31 +A300 -SF1 1² / 17AWG WH X06:7 32 /21.0 1 2 3 4 5 6 7 8 9 Negativ signal required Status Relay /11.88045 Friedrichshafen Tel.Koliwer Maybachplatz 1 D . X54450800010 XZ54400000074 ++ 1 Page of 21 33 .4 4X01:4 WH 1² / 17AWG 4X01:3 WH 1² / 17AWG 4X01:2 WH 1² / 17AWG 4X01:1 WH 2 1² / 17AWG / 18.2014 Michael Moll MTU Friedrichshafen GmbH Approved 12.2012 Parchmann Checked 12.12.3 E-Stop 1² / 17AWG WH X06:8 IN 26 7 /11.GCB Closed /11.2012 Jäger Department OAS Hr.6 0153 1² / 17AWG 0153 DBU -WTB4 +A300 -4X01 8 12 /17.1 4 GCB charged /11.0 mm² NA 1 2 Voltage 0V (-) Voltage 24V (+) 3 4 5 6 7 8 9 21 Negativ signal required GCB closed GCB opened 10 GCB tripped GCB charged GCB close GCB open Interlock 11 12 13 E-Stop E-Stop Spare GND 22 Interlock Control see circuit breaker drawing GCB Option 20 22 Bearbeiter 10.1 +A300-AF20 IN 27 6 GND 1² / 17AWG WH X06:2 1 1² / 17AWG WH X06:1 0 8 9 10 11 10 11 12 13 12 GND Red bridge 4X01: 7-8 Always bridge! For option 3B remove bridge.1 MCB close AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 IN 43 IN 44 OUT 14 11 +A300 -SF1 OUT 11 +A300 -X06 1 2 3 4 / 22.11.3 /20.6 0953 DBU / WH 0953 1 1² / 17AWG / 18.Koliwer Maybachplatz 1 D .12.1 2 GCB opened /11.2 4X01-8 +A300 -X06 6 7 1 2 x 8 1 2 11 12 External customer 1² / 17AWG WH X06:8 4X01:7 WH 1² / 17AWG 1² / 17AWG 4X01:6 WH 5 9 Bridge +CUS -WSNA1 +CUS -SF2 5X01-6 / 22. 3 4 5 6 7 8 9 GND +GCB -TB4 SPARE ÖLFLEX 110 14G1.1 5 GCB open /11.:07541/ 90-3177 Fax:07541/ 903177 GCB-Generator circuit breaker = + Project No.1 3 GCB tripped /11.88045 Friedrichshafen Tel. 1 AGC4 +A300-AF20 +A300 -5X01 1 2 6 7 8 9 / 21. 3 4 5 6 7 GND ÖLFLEX 110 12G1.2014 Michael Moll MTU Friedrichshafen GmbH Approved 12. X54450800010 XZ54400000074 ++ 1 Page of 22 33 .6 0954 0954 DBU / WH 1² / 17AWG / 18.2012 Jäger Department OAS Hr.11.1 +A300-AF20 5X01:1 WH 2 MCB opened /11.12.0 mm² +MCB -TB5 1 2 Voltage 0V (-) Voltage 24V (+) 3 4 5 6 7 21 Negativ signal required MCB closed MCB opened 8 MCB close MCB open Interlock 9 10 11 Spare Spare GND 22 Interlock Spare Control see circuit breaker drawing MCB Spare Spare Spare Option 21 23 Bearbeiter 10.:07541/ 90-3177 Fax:07541/ 903177 = + MCB-Mains circuit breaker Project No.6 0154 0154 DBU 1² / 17AWG 1 3 +A300-AF20 IN 25 -WTB5 2 3 4 5 6 7 8 9 8 9 10 11 10 11 12 GND Red bridge 5X01: 5-6 Always bridge! For option 3B remove bridge.1 4 AGC4 1² / 17AWG / 18.0 1 MCB Closed /11.12.5 OUT 17 4X01-8 5X01:2 WH 1² / 17AWG OUT 8 5X01:5 WH AGC4 +A300-AF20 5X01:4 WH AGC4 IN 24 5 /11.1 MCB open GCB close /11.2012 Parchmann Checked 12.Koliwer Maybachplatz 1 D .3 1² / 17AWG GND 5X01-6 1² / 17AWG / 21.88045 Friedrichshafen Tel. X54450800010 XZ54400000074 ++ 1 Page of 23 33 .6 0964 0964 DBU / WH 1 Coolant Fan 1 5 GND 1 2 3 4 5 6 7 8 9 10 11 3 4 5 6 7 8 9 10 11 12 13 12 GND 1.Koliwer Maybachplatz 1 D .12.6 0164 Fuel Cooler /11.1 /11.88045 Friedrichshafen Tel.2012 Jäger Department OAS Hr.:07541/ 90-3177 Fax:07541/ 903177 = + FAN-Engine fan Project No.12.2012 Parchmann Checked 12.2014 Michael Moll MTU Friedrichshafen GmbH Approved 12.0 mm² +FAN -TB6 1 2 3 4 5 6 7 8 9 10 11 12 13 GND Voltage 0V (-) Voltage 24V (+) GENO Heater Fuel Cooler Fuel Transfer Pump Coolant Fan 1 Coolant Fan 2 Coolant Fan 3 Coolant Fan 4 Room fan on Louver Control see power panel drawing FAN Spare Auxilary CB Tripped Feedback Coolant Fan Failure Ground Option 22 24 Bearbeiter 10.11.1 2 Coolant Fan 2 /11.1 3 1² / 17AWG 0 2 GND ÖLFLEX 110 12G1.5² / 15AWG +A300 -6X01 Fuel Transfer Pump /11.5² / 15AWG 0164 DBU -WTB6 1.1 Auxilary CB/Failure AGC4 +A300-AF20 9 6X01:10 WH IN 48 1² / 17AWG OUT 59 1² / 17AWG OUT 63 1² / 17AWG OUT 61 1² / 17AWG OUT 29 6X01:8 WH AGC4 +A300-AF20 6X01:5 WH AGC4 +A300-AF20 6X01:4 WH AGC4 +A300-AF20 6X01:3 WH AGC4 +A300-AF20 OUT 69 8 /11.1 AGC4 6X01:2 WH / 18.1 6 7 Room fan on /Louver /11.1 4 +A300-AF20 1² / 17AWG / 18. :07541/ 90-3177 Fax:07541/ 903177 = + Spare terminal Project No.1 AGC4 AGC4 AGC4 +A300-AF20 +A300-AF20 -X05 31 2 12 14 19 16 17 18 2117 WH AN_IN 117 1² / 17AWG 2115 WH AN_IN 115 1² / 17AWG 2114 WH AN_IN 114 1² / 17AWG 2113 WH AN_IN 113 1² / 17AWG 2112 WH 1² / 17AWG 2112 WH 1² / 17AWG AN_IN 112 20 General alarm yellow /11.88045 Friedrichshafen Tel.1 External protection tripped /11.2013 Jäger Department OAS Hr.N 3 2080 WH 2 2 3 4 5 6 7 8 9 GND 1² / 17AWG 1 2078 WH 2076 WH -X02 1² / 17AWG 1 1² / 17AWG 0 GND 85 86 87 88 89 VC +A300-AF20 AGC4 /11.1 Fixed load /11. X54450800010 XZ54400000074 ++ 1 Page of 24 33 . Genset to Mains /11.1 Reactive load sharing /11.1 AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 AGC4 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 +A300-AF20 7 Daytank control 8 /11.05.Koliwer Maybachplatz 1 D .1 Spare /11.1 Busbar voltage L1 Negativ signal required Active load sharing /11.1 Day tank no leakage /11.1 +A300-AF20 35 2112 WH 9 IN 50 1² / 17AWG IN 47 1² / 17AWG 2039 WH IN 39 1² / 17AWG 2038 DBU/WH IN 38 1² / 17AWG -X04 2037 WH IN 37 33 3 4 23 25 Bearbeiter 10.1 COM /11.1 Floating load /11.07.1 General fault red /11.05.1 Safety System Override/11.1 Blocking synch.2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2013 Parchmann Checked 21. 05.05. X54450800010 XZ54400000074 ++ 1 Page of 25 33 ..2014 Michael Moll MTU Friedrichshafen GmbH Approved 21.2013 Parchmann Checked 21.07.0 1 2 3 -X02 4 5 6 N -X04 1 2 3 4 5 6 10 11 13 22 -X05 1 5 6 7 8 9 10 11 12 13 -X07 1 2 3 4 5 6 4 5 6 7 8 9 GND 14 0.2013 Jäger Department OAS Hr.88045 Friedrichshafen Tel.:07541/ 90-3177 Fax:07541/ 903177 = + Spare terminal Project No.20mA Analog in +A300 -XMOD 1 2 24 26 Bearbeiter 10.Koliwer Maybachplatz 1 D . 000 Rittal GmbH & Co.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . KG Auflageblock Support bracket 0404428 Phönix Contact GmbH & Co.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300 +A300 +A300 +A300 +A300 +A300 +A300 +A300 +A300 +A300-AF12 +A300-AF20 +A300-FC1 +A300-FC2 +A300-FC2 +A300-FC3 +A300-FC3 +A300-FC4 +A300-FC4 +A300-FC5 Quantity 1 Piece 1840 mm 1300 mm 540 mm 2430 mm 400 mm 3 Piece 2 Piece 8 Piece 0 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece mmo SAP-Order no.88045 Friedrichshafen Tel.750 Rittal GmbH & Co.KG Kabelkanal 80x30 cable duct 80x30 TS8800.KG Kabelkanal 80x80 cable duct 80x80 TS8800.current switch 1NO+1NC 5ST3010 Siemens AG Leitungsschutzschalter C20A/10kA 1polig Circuit-breaker C20A/10kVA 1pol 5SY4120-7 Siemens AG MTU_25_Kunde_D_E 25 26. Manufacturer Designation Order no.753 Rittal GmbH & Co. KG Datenschnittstelle Smart Connect X00E50209782 MTU Friedrichshafen GmbH Genset Kontroller V2-6 Genset Controller V2-6 X59434200175 Deif A/S Leitungsschutzschalter C 6A/10kVA 1polig circuit-breaker C6A/10kVA 1pol 5SY4106-7 Siemens AG Leitungsschutzschalter C10A/10kA 1polig circuit-breaker C10A/10kVA 1pol 5SY4110-7 Siemens AG Hilfsstromschalter 1S+1OE für LS-Schalter Aux. KG Anschlussklemme Terminal clamp 0421029 Phönix Contact GmbH & Co.5 support rail TS35/7.a Bearbeiter 09.05.current switch 1NO+1NC 5ST3010 Siemens AG Leitungsschutzschalter C10A/10kA 1polig circuit-breaker C10A/10kVA 1pol 5SY4110-7 Siemens AG Hilfsstromschalter 1S+1OE für LS-Schalter Aux.5 SZ2317.KG Sammelschiene Schirm 3x10 Bus bar shield 3x10 0402174 Phönix Contact GmbH & Co.KG Tragschiene TS35/7.751 Rittal GmbH & Co. AE Kompakt Schaltschrank AE compact control cabinet AE 1090.KG Kabelkanal 80x40 Kabelkanal 80x40 TS8800.2014 Approved Checked Department OAS Hr. X54450800010 XZ54400000074 ++ 1 Page of 26 33 .009 Rittal GmbH & Co. KG Schirmanschlussklemme Shield bus bar terimal 3025163 Phönix Contact GmbH & Co.current switch 1NO+1NC 5ST3010 Siemens AG Leitungsschutzschalter C 6A/10kVA 1polig circuit-breaker C6A/10kVA 1pol 5SY4106-7 Siemens AG Hilfsstromschalter 1S+1OE für LS-Schalter Aux. :07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.02.99 Finder GmbH Koppel-Relais 24V DC 2 Wechsler 8A Relais 24V DC 2C 8A 40.current switch 1NO+1NC 5ST3010 Siemens AG Leitungsschutzschalter C25A/10kA 1polig circuit-breaker C25A/10kVA 1pol 5SY4125-7 Siemens AG Hilfsstromschalter 1S+1OE für LS-Schalter Aux.52 95.9.52.024. Retaining bracket for 40. SAP-Order no.52 95.KG Modul-Halter 3 Elemente Module holder 3 elements MHR_3 SUR46024005_1 Schlegel GmbH & Co.KG Tastkontaktgeber 1Ö Switch element 1NC MTO SUR46024005_2 Schlegel GmbH & Co.current switch 1NO+1NC 5ST3010 Siemens AG Leitungsschutzschalter C40A/10kA 1polig circuit-breaker C40A/10kVA 1pol 5SY4140-7 Siemens AG Hilfsstromschalter 1S+1OE für LS-Schalter Aux.52.current switch 1NO+1NC 5ST3010 Siemens AG Koppel-Relais 24V DC 2 Wechsler 8A Relais 24V DC 2C 8A 40.01 Finder GmbH Freilaufdiode 6-24VDC Fly back diode 6-24VDC 99.024.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D .52.02.01 Finder GmbH Freilaufdiode 6-24VDC Fly back diode 6-24VDC 99.9.9.05 Finder GmbH Haltebügel für 40.52 95.05 Finder GmbH Haltebügel für 40.83dB Dauerton Alarm horn 18-30VVDC . Hilfsstromschalter 1S+1OE für LS-Schalter Aux.52.024.KG MTU_25_Kunde_D_E 26 26.83dB continuous tone 229025 Eaton GmbH Blindstopfen grau Blanking plug grey 216388 Eaton GmbH NOT-AUS Pilzdrucktaster Emerg. Retaining bracket for 40.52 95. X54450800010 XZ54400000074 ++ 1 Page of 26.a 33 .2014 Approved Checked Department OAS Hr.88045 Friedrichshafen Tel.11.Stop push button RV356 SUR46024005 Schlegel GmbH & Co.0000 Finder GmbH Schraubfassung für 40.0000 Finder GmbH Schraubfassung für 40. Relay socket to 40.b Bearbeiter 10.9.52.024.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-FC5 +A300-FC6 +A300-FC6 +A300-FC7 +A300-FC7 +A300-KF1 +A300-KF1 +A300-KF1 +A300-KF1 +A300-KF2 +A300-KF2 +A300-KF2 +A300-KF2 +A300-PJ1 +A300-PJ1 +A300-PJ1 +A300-SF1 +A300-SF1 +A300-SF1 Quantity 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 1 Piece 0 Piece 0 Piece 0 Piece 0 Piece 1 Piece 1 Piece 1 Piece 1 Piece 3 Piece 1 Piece mmo Manufacturer Designation Order no.99 Finder GmbH Akustikmelder IP40 Alarm horn IP40 229015 Eaton GmbH Summer 24VDC .52. Relay socket to 40. KG Abschlussdeckel D-STI /3 End cover D-STI /3 3030844 Phönix Contact GmbH & Co.b 33 .a 26.KG Tastkontaktgeber 1Ö Switch element 1NC MTO SUR46024005_2 Schlegel GmbH & Co.0A 1N4007 *93270510696* Diotec Semiconductor Standard Diode 1000V/1.KG Modul-Halter 3 Elemente Module holder 3 elements MHR_3 SUR46024005_1 Schlegel GmbH & Co. KG Abschlussdeckel D-PTME 4 End cover D-PTME 4 3212167 Phönix Contact GmbH & Co.0A 1N4007 *93270510696* Diotec Semiconductor UNITRONIC LiYCY 2x0.KG Drucktaster Push button RT Schlegel GmbH & Co.5 3031843 Phönix Contact GmbH & Co. KG Trennplatte ATP-STI /3 Partition plate ATP-STI /3 3030857 Phönix Contact GmbH & Co.5 Installation level terminal block. KG MTU_25_Kunde_D_E 26. KG Trennplatte ATP-STI /3 Partition plate ATP-STI /3 3030857 Phönix Contact GmbH & Co.KG Tasterkappe Push button cap TG22GWS Schlegel GmbH & Co. KG Installationsklemme mit Zugfederanschluss STI 2.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-SF1 +A300-SF3 +A300-SF3 +A300-SF3 +A300-SF3 +A300-SF3 +A300-SF3 +A300-TB10 +A300-V1 +A300-V2 +A300-WCAN_2 +A300-X01 +A300-X01 +A300-X01 +A300-X01 +A300-X01 +A300-X01 +A300-X02 +A300-X02 Quantity 1 Piece 0 Piece 0 Piece 0 Piece 0 Piece 0 Piece 0 Piece 1 Piece 1 Piece 1 Piece 250 mm 1 Piece 1 Piece 180 Piece 1 Piece 1 Piece 1 Piece 2 Piece 2 Piece mmo Designation Order no. X54450800010 XZ54400000074 ++ 1 Page of 26.2014 Approved Checked Department OAS Hr.88045 Friedrichshafen Tel. NS35/7 Snap-on end bracket.KG Einphasige Stromversorgung 230V/ 24VDC/ 40A.c Bearbeiter 10. Single-phase power supply 230V/ 24VDC/ 40A. SAP-Order no.KG Bezeichnungsschild 19x27 gelasert Label laser-cut 19x27 BZ23G Schlegel GmbH & Co. KG Abdeckprofil Cover profil 3202575 Phönix Contact GmbH & Co. KG Lapp GmbH SUR4-68-15352 Phönix Contact GmbH & Co.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . NS35/7 1201442 Abdeckhalter Cover holder 1201468 Phönix Contact GmbH & Co. SDR-960-24 Mean Well Standard Diode 1000V/1. Manufacturer Unterlegschild für Not-Aus gelb Nameplates for emergency-off yellow NAS22 SUR46601015 Schlegel GmbH & Co.34mm² UNITRONIC LiYCY 2xAWG22 0031068 Schnellmontage-Endhalter.KG Schildträger Tag holder RABT Schlegel GmbH & Co. Spring cage connection STI 2.0A Standard diode 1000V/1.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.0A Standard diode 1000V/1.11. 5 Quattro 3030514 Phönix Contact GmbH & Co. NS35/7 3022218 Phönix Contact GmbH & Co. KG SUR4-68-15363 Phönix Contact GmbH & Co.5/4) 3030873 Phönix Contact GmbH & Co. KG Durchgangsklemme mit Zugfederanschluss STTB 2.5-Quattro 0. KG Abschlussdeckel D-ST 2. KG Steckbrücke 3-fach three-point jumper 3030174 Phönix Contact GmbH & Co.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . NS35/7 3022218 Phönix Contact GmbH & Co. KG Deckel D-STTBS 2.b 26. KG Deckel D-STTBS 2.Disconnect terminal 3212139 Phönix Contact GmbH & Co.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.c 33 .5-Quattro 0.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2.08-2.5 Quattro End cover D-ST 2. KG Schutzleiterklemme mit Zugfederanschluss PTMED 4 PE Ground terminal blocks with spring-cage connection PTMED 4 PE 3212154 Phönix Contact GmbH & Co. NS35/7 Snap-on end bracket.5-TWIN 3038516 Phönix Contact GmbH & Co.5²/ 28-12 AWG 3031306 Phönix Contact GmbH & Co. KG Deckel D-ST 10 cover D-ST 10 3036644 Phönix Contact GmbH & Co. Manufacturer Designation Order no. NS35/7 Snap-on end bracket. KG Steckbrücke 4-fach four-point jumper 3030187 Phönix Contact GmbH & Co.5 TWIN cover D-STTBS 2.5 TWIN 3038558 Phönix Contact GmbH & Co.5²/ 28-12 AWG Bottom terminals ST 2.08-2. KG Trennplatte ATP-ST Quattro Seperator plate ATP-ST quattro 3030815 Phönix Contact GmbH & Co. KG Steckbrücke 2-fach two-point jumper 3030161 Phönix Contact GmbH & Co.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-X02 +A300-X02 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X03 +A300-X04 +A300-X04 +A300-X04 +A300-X04 +A300-X05 +A300-X05 Quantity 8 Piece 2 Piece 2 Piece 2 Piece 5 Piece 2 Piece 5 Piece 2 Piece 1 Piece 2 Piece 3 Piece 14 Piece 3 Piece 1 Piece 1 Piece 1 Piece 11 Piece 2 Piece 1 Piece mmo SAP-Order no. Messwandler . KG Reduzierbrücke ST 10-(2.2014 Approved Checked Department OAS Hr. X54450800010 XZ54400000074 ++ 1 Page of 26.Trennklemme Measuring transformer .88045 Friedrichshafen Tel. KG Schutzleiterklemme mit Zugfederanschluss ST6 PE Ground terminal blocks with spring-cage connection ST6 PE 3031500 Schnellmontage-Endhalter. KG Zugfederanschlussklemme ST 2.5 TWIN 3038558 Phönix Contact GmbH & Co. KG Steckbrücke 3-fach three-point jumper 3030174 Phönix Contact GmbH & Co.d Bearbeiter 10. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co. KG MTU_25_Kunde_D_E 26. KG Schnellmontage-Endhalter.11. KG Durchgangsklemme mit Zugfederanschluss ST10 Spring Cage Feed-Through Terminal Blocks 3036110 Phönix Contact GmbH & Co.5/4) reducing jumper ST 10-(2.5 TWIN cover D-STTBS 2. 5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . NS35/7 3022218 Phönix Contact GmbH & Co.5 TWIN PE Ground terminal blocks with spring-cage connection STTB 2.5-TWIN 3038516 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2.5 TWIN 3038558 Phönix Contact GmbH & Co.5-TWIN 3038516 Phönix Contact GmbH & Co. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG MTU_25_Kunde_D_E 26. NS35/7 Snap-on end bracket. KG Schnellmontage-Endhalter.5 TWIN 3038558 Phönix Contact GmbH & Co. NS35/7 3022218 Phönix Contact GmbH & Co.5 TWIN cover D-STTBS 2.5 TWIN 3038532 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. NS35/7 3022218 Phönix Contact GmbH & Co. KG Durchgangsklemme mit Zugfederanschluss STTB 2.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-X05 +A300-X05 +A300-X06 +A300-X06 +A300-X06 +A300-X06 +A300-X07 +A300-X07 +A300-X07 +A300-1X01 +A300-1X01 +A300-1X01 +A300-1X01 +A300-1X02 +A300-1X02 +A300-1X02 +A300-1X02 +A300-2X01 +A300-2X01 Quantity 1 Piece 7 Piece 1 Piece 1 Piece 4 Piece 1 Piece 1 Piece 1 Piece 3 Piece 1 Piece 1 Piece 1 Piece 6 Piece 1 Piece 1 Piece 1 Piece 2 Piece 1 Piece 1 Piece mmo SAP-Order no. X54450800010 XZ54400000074 ++ 1 Page of 26.5 TWIN 3038558 Phönix Contact GmbH & Co.5-TWIN 3038516 Phönix Contact GmbH & Co.5 TWIN cover D-STTBS 2. Manufacturer Designation Order no.5-TWIN 3038516 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG Durchgangsklemme mit Zugfederanschluss STTB 2. NS35/7 Snap-on end bracket.5-TWIN 3038516 Phönix Contact GmbH & Co. KG Schnellmontage-Endhalter.5 TWIN 3038558 Phönix Contact GmbH & Co. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co.d 33 . KG Schutzleiterklemme mit Zugfederanschluss STTB 2.11. KG Deckel D-STTBS 2. NS35/7 Snap-on end bracket.5 TWIN cover D-STTBS 2.88045 Friedrichshafen Tel.5 TWIN cover D-STTBS 2. KG Deckel D-STTBS 2. KG Durchgangsklemme mit Zugfederanschluss STTB 2.5 TWIN cover D-STTBS 2.2014 Approved Checked Department OAS Hr. KG Deckel D-STTBS 2.5 TWIN 3038558 Phönix Contact GmbH & Co. NS35/7 Snap-on end bracket. KG Deckel D-STTBS 2.c 26. Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co. KG Schnellmontage-Endhalter. KG Deckel D-STTBS 2. KG Durchgangsklemme mit Zugfederanschluss STTB 2. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co. NS35/7 3022218 Phönix Contact GmbH & Co. KG Schnellmontage-Endhalter. KG Durchgangsklemme mit Zugfederanschluss STTB 2.e Bearbeiter 10. 5²/ 28-12 AWG Bottom terminals ST 2.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG Deckel D-STTBS 2.5 TWIN cover D-STTBS 2.Disconnect terminal 3212139 Phönix Contact GmbH & Co.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.88045 Friedrichshafen Tel. Manufacturer Designation Order no. KG Schutzleiterklemme mit Zugfederanschluss PTMED 4 PE Ground terminal blocks with spring-cage connection PTMED 4 PE 3212154 Phönix Contact GmbH & Co.Disconnect terminal 3212139 Phönix Contact GmbH & Co. KG Abschlussdeckel D-PTME 4 End cover D-PTME 4 3212167 Phönix Contact GmbH & Co. KG MTU_25_Kunde_D_E 26. X54450800010 XZ54400000074 ++ 1 Page of 26. KG Abschlussdeckel D-PTME 4 End cover D-PTME 4 3212167 Phönix Contact GmbH & Co.Trennklemme Measuring transformer . Durchgangsklemme mit Zugfederanschluss STTB 2.Trennklemme Measuring transformer .Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D .5-Quattro 0.08-2. KG Trennplatte ATP-STI /3 Partition plate ATP-STI /3 3030857 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG Durchgangsklemme mit Zugfederanschluss STTB 2.f Bearbeiter 10. KG Messwandler .2014 Approved Checked Department OAS Hr. KG Zugfederanschlussklemme ST 2. KG Prüfadapter OG Test adapter OG 3035974 Phönix Contact GmbH & Co.5 TWIN 3038558 Phönix Contact GmbH & Co. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co. KG Abschlussdeckel D-ST 2.5 TWIN cover D-STTBS 2. KG SUR4-68-15352 Phönix Contact GmbH & Co.5 Quattro End cover D-ST 2. KG Schaltbrücke Switching jumper 3035755 Phönix Contact GmbH & Co.d 26.e 33 . KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co.11.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2.5-TWIN 3038516 Phönix Contact GmbH & Co.5-TWIN 3038516 Phönix Contact GmbH & Co.5 Quattro 3030514 Phönix Contact GmbH & Co. KG Durchgangsklemme mit Zugfederanschluss STTB 2. KG Messwandler .5 TWIN 3038558 Phönix Contact GmbH & Co. NS35/7 1201442 Prüfadapter BK Test adapter BK 3035980 Phönix Contact GmbH & Co. KG Deckel D-STTBS 2.08-2.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-2X01 +A300-3X01 +A300-3X01 +A300-3X01 +A300-3X02 +A300-3X02 +A300-3X02 +A300-3X02 +A300-3X03 +A300-3X03 +A300-3X03 +A300-3X03 +A300-3X03 +A300-3X03 +A300-3X03 +A300-3X03 +A300-4X01 +A300-4X01 +A300-4X01 Quantity 3 Piece 1 Piece 1 Piece 4 Piece 1 Piece 1 Piece 4 Piece 1 Piece 1 Piece 1 Piece 1 Piece 3 Piece 1 Piece 3 Piece 6 Piece 1 Piece 1 Piece 1 Piece 6 Piece mmo SAP-Order no.5-TWIN 3038516 Phönix Contact GmbH & Co. KG Schnellmontage-Endhalter. NS35/7 Snap-on end bracket.5²/ 28-12 AWG 3031306 Phönix Contact GmbH & Co.5-Quattro 0. 5 TWIN cover D-STTBS 2.5 TWIN 3038532 Phönix Contact GmbH & Co.5-Twin Ground terminal blocks with spring-cage connection ST 2.f 33 .5 TWIN cover D-STTBS 2.5-Twin Bottom terminals ST 2. X54450800010 XZ54400000074 ++ 1 Page of 26.5-TWIN 3038516 Phönix Contact GmbH & Co.5 TWIN 3038558 Phönix Contact GmbH & Co. NS35/7 Snap-on end bracket.5-Twin 3031241 Phönix Contact GmbH & Co. KG Schutzleiterklemme mit Zugfederanschluss STTB 2. KG MTU_25_Kunde_D_E 26. KG Schnellmontage-Endhalter. KG Durchgangsklemme mit Zugfederanschluss STTB 2. KG Deckel D-STTBS 2.5-Twin 3031267 Phönix Contact GmbH & Co.5 TWIN 3038532 Phönix Contact GmbH & Co.5 TWIN Cover D-ST 2. KG Durchgangsklemme mit Zugfederanschluss STTB 2.5 TWIN PE Ground terminal blocks with spring-cage connection STTB 2.5 TWIN 3038532 Phönix Contact GmbH & Co.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG Zugfederanschlussklemme ST 2.0 1 2 3 4 5 6 7 8 9 Bill of material Device designation Page / Position +A300-4X01 +A300-5X01 +A300-5X01 +A300-5X01 +A300-5X01 +A300-6X01 +A300-6X01 +A300-6X01 +A300-6X01 +A300-XMOD +A300-XMOD +A300-XMOD +A300-XMOD Quantity 1 Piece 1 Piece 1 Piece 6 Piece 1 Piece 1 Piece 1 Piece 6 Piece 1 Piece 2 Piece 1 Piece 4 Piece 2 Piece mmo SAP-Order no.11. KG Trennplatte ATP-STTB 4 Seperator plate ATP-STTB 4 3030747 Phönix Contact GmbH & Co. NS35/7 3022218 Phönix Contact GmbH & Co. NS35/7 Snap-on end bracket.5 TWIN PE Ground terminal blocks with spring-cage connection STTB 2. Schutzleiterklemme mit Zugfederanschluss STTB 2. KG Schnellmontage-Endhalter.5 TWIN 3038558 Phönix Contact GmbH & Co. KG Schutzleiter-Reihenklemme ST 2.:07541/ 90-3177 Fax:07541/ 903177 = + Bill of material Project No.e Bearbeiter 10.Koliwer Michael Moll MTU Friedrichshafen GmbH Maybachplatz 1 D . KG Deckel D-ST 2.5-TWIN 3038516 Phönix Contact GmbH & Co. NS35/7 3022218 Phönix Contact GmbH & Co.2014 Approved Checked Department OAS Hr.5 TWIN PE Ground terminal blocks with spring-cage connection STTB 2.5-TWIN Spring Cage Feed-Through Terminal Blocks STTB 2. KG Deckel D-STTBS 2.5 TWIN 3030488 Phönix Contact GmbH & Co. Manufacturer Designation Order no. KG Schutzleiterklemme mit Zugfederanschluss STTB 2.88045 Friedrichshafen Tel.