GRAND CARAVAN C208GRAND CARAVAN C208 Normal & Emergency Checklist CARENADO COPYRIGHTS 2010 GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist NORMAL PROCEDURES CHECKLIST BEFORE STARTING ENGINE Preflight inspection and W&B: Doors: Pax. Briefing: Cabin doors: Crew doors: Parking brake: Seats, belts, harnesses: Switches: Ignition: Circuit breakers: Fuel tank selectors: Radar: Air conditioner: Inverter: Bleed air: Cabin Heat Mixing: Emergency power lever: Power lever: Propeller: Fuel condition lever: Rudder lock: Fuel shutoff: Battery switch: Wing flaps: NS/FSB: Fire detector test: Annunciator panel: Complete Unlocked Complete Latched Unlocked Set Adjusted, secure (check pin) Off Norm Check in Both on Off Off Off Off Flt-Push Normal Idle Full forward Cutoff Turn and push to unlock On (push in) On Up As required Press Test (incl. fuel warning horn) CARENADO COPYRIGHTS 2010 beacon: Suction gauge: Heating. GEN OFF extinguished Normal. defrost: Radios: On Check (24 V minimum) Normal (annunciator) Clear On Check On Check Off Check none Start Check on Check Wait Low idle 80 to 110 lb/hr (1090°C. 2 s) Check Off Check Off Test. ventilation. AUX FUEL PUMP extinguished On On On as required Check As required As required CARENADO COPYRIGHTS 2010 . select 1 or 2 Check Charging. max.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist ENGINE START (BATTERY) Battery: Volt/ammeter: Emergency power lever: Propeller area: Fuel boost: AUX FUEL PUMP ON: FUEL PRESS LOW: Fuel flow: Starter switch: IGNITION ON: Engine oil pressure: Ng > 12%. stable: Fuel condition lever: Fuel flow: ITT: Ng > 52%: Starter switch: STARTER ENERGISED: Inverter: Engine instruments: Generator: Fuel boost: Standby power: Avionics 1 & 2: Nav lights. set Check Normal Check both on Checked Check fully on Set for takeoff 400 ft-lb Check Check. return to BATT Check (torque drop/return) Check Check 1750 ±60 rpm Idle Adjust Check Preflight check Check on Allow 3-4 minutes to stabilize Annun. harnesses: Flight controls: Flight instruments: Fuel boost: Fuel tanks: Fuel quantity: Fuel shutoff: Elevator. Disc. both.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist TAXI Brakes: Flight instruments: Check Check BEFORE TAKEOFF (RUNUP) Park brake: Seats. belts. Alt Select. clutch.) CARENADO COPYRIGHTS 2010 . correct Check.. rudder trim: Power check: Suction: Volt/amps: Inertial separator: Engine instruments: Overspeed governor: Power lever: Quadrant friction: Standby power: Autopilot: Avionics power 1: Gyros: Preflight test: TRIM warning: Electric trim: Set Check secure Full. AP 12x Off (if not. pull AP breaker) Test (L. R. free. aileron. Autopilot: Yaw damper: Flight controls: Disconnect: Trim: Pitot/static heat: Ice protection: Avionics and radar: GPS/Nav switch: Strobe: Annunciators: Wing flaps: Cabin heat mixing: Windows: Brakes: Fuel condition lever: CARENADO COPYRIGHTS 2010 Engage Engage Move to overpower AP Press to test Set for takeoff On if OAT < 4°C As required Check.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Flight director. set Set As required Extinguished or considered 20° Flt-Push Close Release High idle NORMAL TAKEOFF Flaps: Power: Annunciators: Brakes: Rotate: Climb: Flaps: 20° Set for takeoff (See below) Check Release 70-75 KIAS 85-95 KIAS Retract to 10° after 85. up after 95 KIAS . Temperature. [°C] Max.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist SHORT TAKEOFF Flaps: Power: Annunciators: Brakes: Rotate: Climb: Flaps: 20° Set for takeoff (See below) Check Release 70 KIAS 83 KIAS until obstacles cleared Retract to 10° after 85. Op. up after 95 KIAS TAKEOFF POWER LIMIT Pressure Alt [feet] Sea Level 2000 4000 6000 8000 10 000 12 000 Notes: If temperature is above Max. flight is prohibited. up after 95 KIAS TAKEOFF POWER LIMITS s Annunciators: Brakes: Rotate: Climb: Flaps: CARENADO COPYRIGHTS 2010 Check Release 70 KIAS 83 KIAS until obstacles cleared Retract to 10° after 85. Op 50 46 42 38 34 30 26 Tq Limit 42 36 30 21 8 -5 -21 .. torque) ITT < 740°C for normal operations CARENADO COPYRIGHTS 2010 CRUISE Ice protection: As required Pitot/static heat: On if OAT < 4°C Propeller: 1600-1900 rpm Power: Set per cruise power tables ITT < 740°C for normal operations . Ng.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist ENROUTE CLIMB (CRUISE CLIMB) Ice protection: As required Pitot/static heat: On if OAT < 4°C Airspeed: 110-120 KIAS Propeller: 1600-1900 rpm Torque: Set within limits (ITT. Ng. torque) ITT < 740°C for normal operations ENROUTE CLIMB (MAXIMUM PERFORMANCE) Ice protection: As required Pitot/static heat: On if OAT < 4°C Airspeed: 104 KIAS (to 10 000’). 87 KIAS (20 000’) Propeller: 1900 rpm Torque: 1865 ft-lb (ITT. R on High idle Max (forward) Standby/Off Off As desired CARENADO COPYRIGHTS 2010 NORMAL LANDING Flaps: Full Airspeed: 75-85 KIAS Touchdown: Main wheels first Power: Beta after touchdown Brakes: As required Note: Remove reverse before 25 kts . belts.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist DESCENT Ice protection: Pitot/static heat: NS/FSB: Altimeter: GPS/Nav switch: Power: As required On if OAT < 4°C As required Set Set As required BEFORE LANDING Seats. harnesses: Fuel selectors: Fuel condition lever: Propeller control lever: Radar: Autopilot: Wing flaps: Secure L on. until obstacles are cleared Retract at safe altitude and airspeed AFTER LANDING Flaps: Ice protection: Strobes: Landing and taxi lights: Fuel condition lever: Up Off Off As required Low idle when clear of runway .GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist SHORT FIELD LANDING Flaps: Full Airspeed: 78 KIAS Power: Idle after clearing obstacles Power: Beta (against spring) after touchdown Brakes: Heavy braking with full up elevator Wing flaps: Retract if at light weight Note: Remove reverse before 25 kts BALKED LANDING Power: Flaps: Airspeed: Flaps: CARENADO COPYRIGHTS 2010 Full takeoff power 20° 80 KIAS min. temperature for 1 min Propeller: Feather Fuel condition lever: Cutoff Oxygen: Off Lights: Off Battery: Off Controls: Lock Fuel tank selectors: Both off Tiedowns and chocks: As required External covers: Install Fuel filter: Check bypass flag Oil breather drain can: Drain CARENADO COPYRIGHTS 2010 . ventilation fans.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist SHUTDOWN Parking brake: Set Avionics: Off Standby power: Off Fuel boost: Off Bleed air. air conditioner: Off Inverter: Off Power lever: Idle ITT: Min. or On if cycling High idle CARENADO COPYRIGHTS 2010 . rpm Cutoff On (push in) L on. R on On On Check on Check off 20 000’ maximum Start Check on Check 12% minimum Low idle Monitor 1090°C max.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist C208 ABNORMAL CHECKLIST AIR START (STARTER--PREFERRED) Electrical load: Standby power: Avionics power: Ignition: Air conditioner: Bleed air heat: Emergency power lever: Power lever: Propeller: Fuel condition lever: Fuel shutoff: Fuel tank selectors: Battery switch: Fuel boost switch: AUX FUEL PUMP: FUEL PRESS LOW: Altitude: Starter switch: IGNITION ON: Engine oil pressure: Ng: Fuel condition lever: ITT: Ng: Starter switch: Ignition: Fuel boost pump: Fuel condition lever: Reduce Off Off Normal Off Off Normal Idle Min. low fuel) Normal. 52% minimum Off On if required (rain. GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Propeller control: Power lever: Electrical equipment and avionics: AIR START (WINDMILLING) Generator switch: Standby power: Avionics power: Air conditioner: Bleed air heat: Emergency power lever: Power lever: Propeller: Fuel condition lever: Fuel shutoff: Fuel tank selectors: Battery switch: Fuel boost switch: AUX FUEL PUMP: FUEL PRESS LOW: Ignition switch: Airspeed: Altitude: Ng indicator: Fuel condition lever: ITT: Ng: Ignition: As desired As desired As required Trip and release Off Off Off Off Normal Idle Min. R on On On Check on Check off On 100 KIAS minimum (140 if feathered) 20 000’ maximum (15 000’ if feathered) Check stable and non-zero Low idle Monitor 1090°C max. rpm Cutoff On (push in) L on. 52% minimum On if required (rain. low fuel) CARENADO COPYRIGHTS 2010 . GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Fuel boost: Fuel condition lever: Propeller control: Power lever: Generator: Electrical equipment and avionics: ASYMMETRIC FLAP Aileron: Flap selector: Airspeed: If flaps retract symmetrically: If flaps remain asymmetric: At least 90 KIAS on the approach Avoid nose-high flare on landing CARENADO COPYRIGHTS 2010 Normal. Standby flap system has no limit switches LANDING WITH FLAT MAIN TIRE Fuel: Approach: Touchdown: Fly to lighten load on flat side Normal (full flap) Inflated tire first . or On if cycling High idle As desired As desired Reset and release As required Apply to stop the roll Up Slow to 100 KIAS or less Flapless landing Land as soon as practical FLAPS FAIL TO EXTEND OR RETRACT Flap Motor/Standby Flap Motor CBs: Check in If flaps still fail to operate: Standby switch: Standby Standby flap up/down: As required Notes: Later models require breaking safety wire. GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist LANDING WITH FLAT NOSEWHEEL TIRE Passengers and baggage: Approach: Touchdown: Brakes: Move aft if possible Normal (full flap) Nose high Minimum necessary BATTERY TEMPERATURE HIGH (AMBER) Battery: Ammeter: If ammeter shows charge: Generator: Standby power: All electrical switches: Off Bus 1 Pwr/Bus 2 Pwr CBs: Avionics switches: Standby power: Avionics standby power: Avionics bus tie: Reinstate essential circuits: Land as soon as practical GENERATOR FAILURE Voltmeter: Bus 1/Bus 2 CBs: If V < 24.5 V: Volt/ammeter: If generator output zero: GEN CONT/GEN FIELD CBs: Generator: Check (annunciator failure?) Check. on Lift guard. do not reset! Gen (monitor ammeter) In Reset and release Off Check in BATT position Trip and release Off Pull off (6!) Off On Lift guard. on Monitor load CARENADO COPYRIGHTS 2010 . : Off GEN CONT/GEN FIELD: Pull AP CONT or AP FD: Pull Land as soon as practical Standby generator: Use if available If generator output resumes: Monitor voltage (over 29 V will probably trip again) STARTER DOES NOT DISENGAGE Battery: Auxiliary power unit: Fuel condition lever: Engine shutdown: Off Off then disengage Cutoff Complete CARENADO COPYRIGHTS 2010 UPPER HALF OF CARGO/AIRSTAIR DOOR OPEN Airspeed: Wing flaps: Door: Land: Less than 100 KIAS Full (to provide downwash) Close if helper available Normal approach and landing .GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Electrical load: Reduce Avionics 2: Off Flashing beacon: Off Strobes: Off De-icing: Off (keep 1 pitot!) Vent fans: Off Air cond. GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist LOWER HALF OF AIRSTAIR DOOR OPEN Airspeed: Return for landing Wing flaps: Land: Less than 100 KIAS Full Slightly tail low. avoid nose high flare CREW DOOR OPEN Airspeed: Door: CARGO POD DOOR(S) OPEN Airspeed: Land as soon as practical Approach: Landing: Less than 100 KIAS Normal Avoid nose-high flare Less than 100 KIAS Pull closed and latch CARENADO COPYRIGHTS 2010 . harnesses: Flaps: Airspeed: Field: Switches: Flaps: Secure 10° 90 KIAS Select. belts. 80 KIAS (full flap) Idle Feather Cutoff Off Normal Off Off Off (pull out) Off (warning horn) As required (full recommended) Unlatch before touchdown Off when landing is assured Slightly tail low Apply heavily CARENADO COPYRIGHTS 2010 . check terrain and obstacles All off except Generator and Battery Full down Secure 100 KIAS (flaps up). harnesses: Airspeed: Power lever: Propeller: Fuel condition lever: Fuel Boost: Ignition: Standby power: Nonessential equipment: Fuel shutoff: Fuel tank selectors: Wing flaps: Crew doors: Battery: Touchdown: Brakes: PRECAUTIONARY LANDING Seats.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist C208 EMERGENCY CHECKLIST EMERGENCY LANDING WITHOUT POWER Seats. belts. fly over. belts. harnesses: Flaps: Power: Approach: Face: Touchdown: Evacuate Life vests and rafts: ENGINE FIRE IN FLIGHT Power lever: Propeller: Fuel condition lever: Fuel shutoff: Cabin heat firewall shutoff: Forward side vents: Overhead vents: Ventilation fans: Wing flaps: Airspeed: Forced landing: 80 KIAS Unlatch before touchdown Trip and release Off Slightly tail low Cutoff Apply heavily CARENADO COPYRIGHTS 2010 Mayday on 121.GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Airspeed: Crew doors: Generator: Battery: Touchdown: Fuel condition lever: Brakes: DITCHING Radio: Heavy objects: Seats.5 MHz. squawk 7700 Secure if passenger available Secure Down 300 fpm descent at 80 KIAS Into heavy wind or parallel to swells Cushion using padding No flare Inflate outside cabin Idle Feather Cutoff Off (pull out) Pull off Close Open On 20 to 30° 80-85 KIAS Execute . GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist BATTERY OVERHEATED (RED) Battery: Generator: Standby power: All electrical switches: Bus 1 Pwr/Bus 2 Pwr CBs: Avionics switches: Standby power: Avionics standby power: Avionics bus tie: Reinstate essential circuits: Land as soon as practical ELECTRICAL FIRE IN FLIGHT Battery: Off Generator: Trip and release Standby power: Off Vents: Close to avoid drafts Bleed air heat: Off Fire extinguisher: Activate Oxygen: Use until smoke clears Avionics power: Off All other switches: Off If fire appears out and electrical power necessary: Battery switch: On Standby power: On Generator: Reset and release Circuit breakers: Check. on Lift guard. do not reset Inverter: 1 or 2 if required Off Trip and release Off Off Pull off (6 breakers) Off On Lift guard. on Monitor load CARENADO COPYRIGHTS 2010 . GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Radio switches: Avionics power switches: Radio and electrical switches: Vents: Bleed air heat: CABIN FIRE Battery: Generator: Standby power: Vents: Bleed air heat: Fire extinguisher: Oxygen: Land as soon as possible CARENADO COPYRIGHTS 2010 Off On On one at a time. Stall heat: Strobe lights: Navigation lights: Landing and taxi lights: Radar: Ventilation fans: Sideslip if required. delay Open when fire completely extinguished On as desired Off Trip and release Off Close to avoid drafts Off Activate Use until smoke clears WING FIRE Pitot/static heat. land as soon as possible Off Off Off Off Off Off . GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist CABIN FIRE ON GROUND Power lever: Brakes: Propeller: Fuel condition lever: Battery: Evacuate Fire: Idle As required Feather Cutoff Off Extinguish ENGINE FIRE DURING START ON GROUND Fuel condition lever: Fuel boost: Starter switch: Fuel shutoff: Starter: Battery: Evacuate Fire: Cutoff Off Motor (within starter limits) Off (pull out) if fire persists Off if fire ceases Off Extinguish CARENADO COPYRIGHTS 2010 FCU PNEUMATIC/GOVERNOR MALFUNCTION Power lever: Emergency power lever: LOSS OF FUEL PRESSURE Fuel boost pump: If FUEL PRESS LOW extinguishes: Monitor fuel quantity. cabin outdoors On Idle As required (Ng > 65%) . R on On On Seats. belts. belts. harnesses: Power lever: Propeller: Wing flaps: Airspeed: Secure Idle Full forward Up VA (148 to 112 KIAS) EMERGENCY DESCENT: SMOOTH AIR Seats. harnesses: Power lever: Propeller: Wing flaps: Airspeed: Secure Idle Full forward 10° VMO (175 KIAS) .GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist Land as soon as practical If FUEL PRESS LOW/AUX FUEL PUMP ON: Monitor engine gauges for fuel starvation Land as soon as possible FUEL RESERVOIR LOW Fuel tank selectors: Ignition: Fuel boost: If sufficient fuel in wing tanks: Monitor gauges and FUEL PRESS LOW Land as soon as possible and investigate If there are signs of fuel starvation: Prepare for forced landing EMERGENCY DESCENT: ROUGH AIR CARENADO COPYRIGHTS 2010 L on. GRAND GRAND CARAVAN C208 CARAVAN C208 Normal & Emergency Checklist CARENADO COPYRIGHTS 2010 .